Abstract:Carbon emissions have become a prominent global concern, with the utilization of fossil fuels serving as the primary contributor. Ammonia, being a hydrogen carrier without carbon, has the potential to be utilized through combustion, resulting in the production of water and nitrogen as ideal byproducts, which are environmentally benign. However, individual ammonia is difficult to combust due to its unfavorable combustion characteristics. Hence, ammonia needs to be blended with other fuels that possess superior combustion characteristics. Additionally, NH 3 inherently contains a significant amount of nitrogen, a fuel element that can contribute to the increased release of NO x emissions. In this work, a simulation was conducted using CHEMKIN to investigate the nitrogen transformation characteristics during ammonia/coal co-firing under deeply air-staged combustion. Experimental studies primarily focus on macroscopic factors, such as temperature and pressure, while often neglecting the analysis of reaction mechanisms. The utilization of the chemical reaction kinetics simulation method can provide valuable insights into the reactions and substances that exert the most significant impact on the formation of NO x , as well as elucidate the pathway of fuel-nitrogen conversion during combustion. Simulation results demonstrate that as the NH 3 co-firing ratio (CR-NH 3 ) increases, the volume content of NO x initially rises, reaching its peak at approximately 10% CR-NH 3 , and subsequently declines. The conversion rate of NO x increases as the combustion temperature in the primary combustion area rises. The primary reactions have a greater influence on the formation of NO at low-temperature conditions. However, it is important to note that low temperature also decreases the combustion efficiency. The incorporation of overfire air (OFA) in advance has the potential to mitigate nitrogen reduction in the primary combustion area, while simultaneously improving NO x emissions. With the oxygen concentration of primary air increased, the conversion rate of NO x gradually decreases. It undergoes a sharp change before reaching 21% oxygen concentration, after which it levels off. In addition, high oxygen concentration increases the pathway of NO consumption. When the excess air coefficient of OFA falls within the range of 0.35–0.45, the NO x conversion rate can be minimized. The present study aims to offer technical assistance and guidance for effectively controlling NO x emissions in ammonia/coal co-firing boilers.

Experimental Investigation of NOx Emission and Ash-Related Issues in Ammonia/coal/biomass Co-Combustion in a 25-Kw Down-Fired Furnace

Experimental Investigation of Combustion and Ash Deposition Characteristics of Coal-Nh3 Cofiring in a 200 Kw Furnace

A Direct Numerical Simulation Study on Combustion and NO Formation of Coal/ammonia Co-Firing Flames

Chemical Suppressive Effect of Ammonia Addition on Soot Formation in Laminar Diffusion Flames

Numerical Investigation on Pyrolysis and Ignition of Ammonia/coal Blends During Co-Firing

Optical diagnostics on coal ignition and gas-phase combustion in co-firing ammonia with pulverized coal on a two-stage flat flame burner

Co-firing characteristics and fuel-N transformation of ammonia/pulverized coal binary fuel

Measurements and Modelling of Oxy-Fuel Coal Combustion

Probing into Volatile Combustion Flame and Particulate Formation Behavior During the Coal and Ammonia Co-firing Process

Experimental study on co-firing characteristics of ammonia with pulverized coal in a staged combustion drop tube furnace

Experimental Investigation on Fine Particle Formation in Ammonia/Biomass Co-combustion

Experimental Study of NH3 and Coal Co-firing in a CFB and Its Nitrogen Conversion

Industrial scale testing on the combustion and NO emission characteristics of ammonia cofiring in a 40 MWth coal-fired boiler

Experimental study and kinetic analysis of NO emission characteristics in ammonia/coal co-firing process with different ammonia injection methods

Combustion characteristics and nitrogen conversion mechanism in ammonia/coal Co-firing process

Comprehensive Effect of the Coal Rank and Particle Size on Ammonia/coal Stream Ignition

Effects of ammonia on combustion of coal in stoichiometric premixed methane–air flames

Experimental Study of Effect of a Novel Ammonia/coal Co-Firing Mode on NOx Emission under High Temperature Conditions

A Novel Low-Nox Swirl Burner with Coal-Ammonia Co-Firing: Effect of Ammonia Ratio in the Dual Channels on Combustion and NOx Formation

Probing into Volatile Combustion Flame and Particulate Formation Behavior during the Coal and Ammonia Cofiring Process: Further Study on the Chemical Structure and Oxidation Reactivity of Soot Particles

Simulation study on nitrogen transformation characteristics of NH 3 /Coal Co-firing under deeply air-staged condition