Abstract:In this paper, 2 atom % Al-doped ZnO (AZO) was prepared by the co-precipitation method together with sparking plasma sintering (SPS) treatment. The as-synthesized AZO powders show the morphology of hollow hexagonal towers, which result in a high porosity of 50.6% in the bulk sample consolidated by SPS sintering at 400 °C, and the porosity decreases gradually with increasing sintering temperature up to 1000 °C. Positron annihilation measurements reveal that even after sintering at 1000 °C, there are still a considerable number of small pores. A high electrical conductivity of 3 × 105 S m–1 is achieved at room temperature for the AZO sample sintered at 1000 °C, while the absolute values of Seebeck coefficient keep at relatively high values between 59 and 144 μV K–1 in the measurement temperature range of 27–500 °C, leading to a high power factor of 3.4 × 10–3 W m–1 K–2. On the other hand, the pores in AZO act as strong phonon scattering centers, and an extremely low thermal conductivity of 1.5 W m–1 K–1 measured at room temperature is obtained for AZO sintered at 400 °C. Due to the residual pores in the 1000 °C-sintered sample, the thermal conductivity is still relatively low. As a result, a maximum ZT of 0.275 measured at 500 °C is obtained in this sample, which is the highest ZT reported for ZnO around this temperature.The Supporting Information is available free of charge at <a class="ext-link" href="/doi/10.1021/acsami.0c16506?goto=supporting-info">https://pubs.acs.org/doi/10.1021/acsami.0c16506</a>.Thermal gravity analysis for the Al-doped ZnO (Figure S1), TEM images of Al-doped ZnO sintered at different temperatures (Figure S2), and structural characterization and thermoelectric properties of undoped ZnO prepared by co-precipitation combined with SPS treatment (Figures S3–S5) (<a class="ext-link" href="/doi/suppl/10.1021/acsami.0c16506/suppl_file/am0c16506_si_001.pdf">PDF</a>)This article has not yet been cited by other publications.

Study of Low Temperature Preparation of Al Doped ZnO Powder and its Photocatalytic Properties

Surface Topography and Optical Properties of Al-doped ZnO Thin Films by Sol-gel Process

Preparation and Characterization of Na-doped ZnO Thin Films by Sol–gel Method

Preparation and Characterization of Mg-doped ZnO Thin Films by Sol–gel Method

Study of the Photocatalytic Activity of Na and Al-doped ZnO Powders

Temperature annealing and aluminum atomic concentration effect on structural, morphological and optical properties of ZnO-Al2O3 nanocomposites powders and photocatalytic performances

Preparation of highly efficient Al-doped ZnO photocatalyst by combustion synthesis

Low Temperature Calcination of TiO2 and ZnO Particle Film and Evaluation of Their Photocatalytic Activity

Effect of Al-doping on morphology, structure, and optical band gap of ZnO thin films synthesized by sol–gel spin-coating technique

Synthesis, characterization and photocatalytic property of nanostructured Al-doped ZnO powders prepared by spray pyrolysis

Study on Microstructure and Electrical Properties of ZnO:Al Thin Films Prepared by Sol-gel Method

Study on the regulation mechanism of Al doping on the controllable photocatalytic performance of the ZnO@MgAl-LDH nanocomposite

In-Situ Doping Preparation of Al-Doped Zno Films Via Pulsed Laser Co-Ablation of Zn and Al Targets with Assistance of Oxygen Plasma

Preparation, Characterisation and Photocatalytic Activity of La-doped ZnO Nanopowders Synthesised Using Auto-combustion

X-ray Diffraction, XPS, and Raman Spectroscopy of Coated ZnO:Al (1—7 at%) Nanoparticles

Significant Enhancement in the Thermoelectric Performance of Aluminum-Doped ZnO Tuned by Pore Structure

Optimization of the Process for Preparing Al-doped ZnO Thin Films by Sol-Gel Method

Preparation of aluminum-doped zinc oxide (AZO) nano particles by hydrothermal synthesis

Study on Aluminum Concentration on Optical and Electrical Properties of AZO Thin Films Fabricated by Ultrasonic Spray Pyrolysis

A study on the Al doping behavior with sol aging time and its effect on structural and optical properties of sol-gel prepared ZnO thin films

Doping of Zinc Oxide with Selected First Row Transition Metals for Photocatalytic Applications