Abstract:The utilization of powdery semi-coke as a power fuel in pulverized coal-fired power plants has become a new and potential technique to consume the excess powdery semi-coke. The characteristic of low volatile results in poor combustion performance and high NOx emission, and to co-fire with bituminous coal is a practical strategy to address this problem. However, the co-combustion characteristics and the inherent interaction between semi-coke and coal remain insufficiently understood. In addition, the influences of secondary air arrangement, the boiler operation load, and the fuel type on co-combustion process are still unclear, which is urgent to be further explored. In the present study, experiments and numerical simulations were jointly utilized to inquire into the co-combustion behaviors and NOx emission features of semi-coke and coal. The results demonstrated that the “out-furnace method” was a suitable choice for small-capacity boiler when the proportion of semi-coke was 33%, due to the limited combinations of the semi-coke injection position. It was recommended that semi-coke was preferred to be injected from the middle layers of the furnace under the “in-furnace method” to improve the overall co-combustion performance. The critical value of the separated over fire air ratio in this study was 27.5%, over which a slight drop of carbon content in fly ash could come about. Moreover, the elevation in the proportion of separated over fire air gave rise to the significant decline of NOx concentration. The constricted secondary air arrangement was preferred to be employed due to the high boiler efficiency. The separated over fire air and the surrounding air needed to maintain a wide-open degree to prevent the increase of NOx emissions and the coking of nozzles. For the load reduction regulation method adopted in this study, the NOx concentration first rose and then dropped, while the burnout ratio decreased obviously as the operation load was reduced. Different combinations of coal and semi-coke generated significant influences on co-combustion behaviors within the furnace. The NOx generated by high-volatile fuel (bituminous coal) combustion was mainly affected by volatile-N, while the NOx generated by low-volatile fuel (semi-coke) was mainly impacted by char-N. This study is of guiding significance for the efficient and clean utilization and beneficial to the large-scale application of powder semi-coke in power plants.

Study on semi-coke as an alternative fuel for blast furnace injection coal

Numerical Study on Combustion Behavior of Semi-Coke in Blast Furnace Blowpipe-Tuyere-Combustion Zone

Co-combustion of semicoke and coal in an industry ironmaking blast furnace: Lab experiments, model study and plant tests

Non-isothermal Thermogravimetric Investigation on Mutual Effect Between Bituminite and Anthracite in Blends for Blast Furnace Injection

Experimental investigation on ignition and burnout characteristics of semi-coke and bituminous coal blends

Enhancement of hybrid combustion of semi-coke and bituminous coal by rare earth oxides

Experimental and Numerical Study on Co-combustion Behaviors and NOx Emission Characteristics of Semi-coke and Coal in a Tangentially Fired Utility Boiler

Experimental investigation on combustion and NO formation characteristics of semi-coke and bituminous coal blends

Experimental study on the combustion and NOx emission characteristics of a bituminous coal blended with semi-coke

Correction To: Thermal Analysis and Kinetic Modeling of Pulverized Coal Combustion Accompanied with Coke Breeze

Study on improving the performance of blended Semi-coke coal water slurry based on multi-peak gradation technology

Experimental Study on Combustion Behaviors and Carbon Monoxide Emission Characteristics of Single Coal Pellets

Numerical simulation of co-combustion characteristics of semicoke and coke breeze in an ironmaking blast furnace

Computational fluid dynamics investigation on the effect of co-firing semi-coke and bituminous coal in a 300MW tangentially fired boiler

Numerical Investigation on Co-firing Characteristics of Semi-Coke and Lean Coal in a 600 MW Supercritical Wall-Fired Boiler

Kinetic Study on Co-Combustion of Pulverized Anthracite and Bituminite for Blast Furnace Injection

Experimental Study of Commercial Charcoal As Alternative Fuel for Coke Breeze in Iron Ore Sintering Process

Experimental Evaluation on Co-Combustion Characteristics of Semi-Coke and Coal under Enhanced High-Temperature and Strong-Reducing Atmosphere

Experimental Investigation on Combustion Characteristics and Kinetics During Co-Firing Bituminous Coal with Ultra-Low Volatile Carbon-Based Solid Fuels

Coke Substitution with Anthracite in Sintering Production

Investigation on co-combustion of semi-coke and bituminous coal in oxygen-enriched atmosphere: Combustion, thermal conversion, and kinetic analyses