Abstract:Dry Anaerobic Digestion (AD) presents different advantages if compared to wet AD, i.e. smaller reactor size, lesser water addition, digestate production and pretreatment needed, although several studies have demonstrated that water promotes substrate hydrolysis and enables the transfer of process intermediates and nutrients to bacterial sites. To better understand the role of water on AD, dry and semidry digestion tests of selected complex organic substrates (food waste, rice straw, carrot waste), with various TS contents of the treated biomass have been carried out in the present study. The results confirm that water plays an essential role on the specific methane production rate, final methane yield and Volatile Solids (VS) degradation. The final methane yield in semi-dry and dry conditions was 51% and 59% lower for rice straw and 4% and 41% lower for food waste, respectively, if compared with wet conditions. Inhibition tests, based on Volatile Fatty Acid (VFA) analysis, were carried out to investigate the specific inhibition processes that take place with the selected substrates at different TS contents. In wet AD of carrot waste no VFA accumulation was found, and all VFA concentrations were lower than the inhibition limits. A direct correlation between TS content and total VFA (TVFA) concentration was noticed for rice straw and food waste AD. For rice straw a maximum TVFA concentration of 2.1 g/kg was found in dry condition, 1 g/kg in semidry conditions and 0.2 g/kg in wet conditions, whereas for food waste the TVFA concentration was 10 g/kg in dry condition, 9 g/kg in semidry conditions and 3 g/kg in wet conditions. A Mathematical model of complex organic substrate AD in dry and semidry conditions has been proposed to simulate the effect of TS content on the process. The data obtained from batch experiments, in terms of methane production and VFA concentrations, were used to calibrate the proposed model. The kinetic parameters of VFA production and degradation, calibrated using the experimental data, resulted highly dependent on the TS content and different from wet AD literature values. This is due to VFA accumulation in dry conditions, which implies higher values of the inhibition factors introduced in the model. Finally, as dry AD takes usually place in Plug Flow (PF) reactors, an historical and critical review on the role of hydrodynamics in PF bioreactors has been carried out

A dynamic simulation of methane fermentation process receiving heterogeneous food wastes and modelling acidic failure

Examining a Pretty Simple and Low Cost Method for Modeling of Biogas Production from Biodegradable Solids

The Response of Biogas Production and Methanogenic Community to the Variation of Intermediate Vfas Produced During the Anaerobic Digestionof Food Waste

A novel approach for the fractionation of organic components and microbial degraders in ADM1 and model validation based on the methanogenic potential

Dynamic Behaviors of Batch Anaerobic Systems of Food Waste for Methane Production under Different Organic Loads, Substrate to Inoculum Ratios and Initial Ph.

Variation of volatile fatty acid oxidation and methane production during the bioaugmentation of anaerobic digestion system: Microbial community analysis revealing the influence of microbial interactions on metabolic pathways

Simulation models of microbial community, pH, and volatile fatty acids of anaerobic digestion developed by machine learning

Case specific: Addressing co-digestion of wastewater sludge, cheese whey and cow manure: Kinetic modeling

Anaerobic Co-Digestion of Municipal Biomass Wastes and Waste Activated Sludge: Dynamic Model and Material Balances

Modeling key intermediates during anaerobic digestion of lipid rich kitchen waste with an extended ADM1

Inhibition Mechanisms of Ammonia and Sulfate in High-Solids Anaerobic Digesters for Food Waste Treatment: Microbial Community and Element Distributions Responses

Bio-methanation tests and mathematical modelling to assess the role of moisture content on anaerobic digestion of organic waste

Acidogenic Fermentation of Food Waste for Production of Volatile Fatty Acids: Bacterial Community Analysis and Semi-Continuous Operation.

Methanogenic Community Dynamics in Anaerobic Co-Digestion of Fruit and Vegetable Waste and Food Waste

Strategy to enhance the semicontinuous anaerobic digestion of food waste via exogenous additives: experimental and machine learning approaches

Approach of Describing Dynamic Production of Volatile Fatty Acids from Sludge Alkaline Fermentation

Responses of anaerobic digestion of food waste to coupling effects of inoculum origins, organic loads and pH control under high load: Process performance and microbial characteristics

Modeling of acetate-type fermentation of sugar-containing wastewater under acidic pH conditions.

Long-term semi-continuous acidogenic fermentation for food wastes treatment: Effect of high organic loading rates at low hydraulic retention times and uncontrolled pH conditions

Biochar-promoted methane production and mitigation of acidification during thermophilic anaerobic co-digestion of food waste with crude glycerol: comparison with re-inoculation

Microbial internal storage alters the carbon transformation in dynamic anaerobic fermentation