Abstract:Human urine is characterized by high concentrations of nitrogen (N), phosphorus (P) and potassium (K), of which the P and K can be recovered as K-struvite crystals. This study first investigated the formation of Na-struvite because of the high Na+ present in the urine. From the results, the optimal pH for the Na-struvite crystallization was observed to be 12, and the rise in the Na+ concentration distinctly favored the Na-struvite formation. As magnesium needed to be added to induce the K-struvite crystallization, several magnesium sources including MgCl2, Mg sacrificial electrode and Mg(OH)2 were applied to recover P and K from synthetic urine. The findings indicated that when MgCl2 was used as the magnesium source, the K removal could be slightly enhanced by prolonging the reaction time, which would correspondingly decrease the Na concentration in the precipitates; besides, the intermittent addition of MgCl2 could noticeably improve the removal efficiency of K by 6%, but simultaneously raise the Na content in the precipitates recovered. With respect to the use of the Mg sacrificial electrode, the recovery efficiencies of the P and K from synthetic urine were close to those with the use of MgCl2. However, when Mg(OH)2 was used as the magnesium source, the recovery efficiencies of P and K achieved only roughly 50%, which was much lower than those noted when MgCl2 and the Mg sacrificial electrode were employed. A comprehensive analysis revealed that the MgCl2 was the best magnesium source for the K-struvite crystallization, followed by the Mg sacrificial electrode and Mg(OH)2.

Dehydration characteristics of struvite-K pertaining to magnesium potassium phosphate cement system in non-isothermal condition

Continuous reaction crystallization of struvite from phosphate(V) solutions containing calcium ions

Effect of K+ Diffusion on Hydration of Magnesium Potassium Phosphate Cement with Different Mg/P Ratios: Experiments and Molecular Dynamics Simulation Calculations

A method for determining the hydration degree of magnesium potassium phosphate cements

Compositional Dependence of Pore Structure, Strengthand Freezing-Thawing Resistance of Metakaolin-Based Geopolymers

An investigation on hydration products of MKPC at low magnesium to phosphate ratio using XRD Rietveld Method

Understanding hydration process and paste viscosity evolution of magnesium potassium phosphate cement

Calorimetric Study of Magnesium Potassium Phosphate Cement

Mechanical properties of struvite-K: A high-pressure X-ray diffraction study

Gas Chromatographic Thermodynamics on Hydration Processes of Magnesium Chloride with Low Water

Chemical–physical–mechanical Stability of MKG Mortars under Sulfate Attacks

Cs+ Promoting the Diffusion of K+ and Inhibiting the Generation of Newberyite in Struvite-K Cements: Experiments and Molecular Dynamics Simulation Calculations

Alleviating Na+ Effect on Phosphate and Potassium Recovery from Synthetic Urine by K-struvite Crystallization Using Different Magnesium Sources.

Solidification/stabilisation behaviours of Zn2+ in magnesium potassium phosphate cement: Experiments and density functional theory study

Effect of seawater on hydration of magnesium potassium phosphate cements

Potentiometric Study of the Formation of Magnesium Potassium Phosphate Hexahydrate

Dehydration Behavior of FGD Gypsum by Simultaneous TG and DSC Analysis

Comparison of Different K-struvite Crystallization Processes for Simultaneous Potassium and Phosphate Recovery from Source-Separated Urine.

Chemical degradation of magnesium potassium phosphate cement pastes during leaching by demineralized water: Experimental investigation and modeling

Influence of curing conditions on mechanical properties and microstructure of magnesium potassium phosphate cement

Effect of temperature and pH value on the stability of magnesium potassium phosphate hexahydrate