Abstract:Many materials essential to the European Union's (EU) economy lack primary resources, and the major suppliers of these materials are non-EU nations. It has been determined that seawater reverse osmosis (SWRO) desalination brines are a circular answer for the supply of critical elements. SWRO desalination brines, however, are distinguished by high concentrations of elements with negligible economic worth. (e.g., Na, Cl) compared to critical elements present in very low concentrations (e.g. Mg, B, Sc, V, In, Ga, Li, Mo, Rb). Therefore, an efficient separation pre-treatment is necessary to maximize the recovery efficiency in a brine extraction process. Nanofiltration (NF) was proposed as pre-treatment stage to separate monovalent from divalent ions and it was investigated if a Ca(II) removal stage was necessary before the NF to avoid scaling. The performances of three polyamide commercial membranes (NF270, Fortilife XC-N and PRO-XS2) treating SWRO brine (brine 1) and Ca(II)-free SWRO brine (after Ca(II) removal with sodium bicarbonate - brine 2) were evaluated in a closed circuit configuration as a function of the applied pressure from 6 to 30 bar. Results showed that NF was an efficient process to separate target elements present in seawater desalination brine into two different streams. Moreover, removal of Ca(II) before the NF step (brine 2) increased the selectivity between multivalent and monovalent species (higher rejection of multivalent and lower rejection of monovalent species compared to brine 1) for all the membranes tested, reaching the highest selectivity at 20 bar. At 20 bar, the polyamide membrane PRO-XS2 presented rejections of 71% for Ca(II) and 89% for Mg(II) and the highest selectivity in experiments with brine 2, being recommended for this application. In addition, the transport of species was characterized by membrane permeances by using the Solution-Electro-Diffusion-Film model. The scaling assessment at the membrane surface showed a lower scaling potential if Ca(II) was removed before the NF stage.

Pilot plant comparison study of two commercial nanofiltration membranes in a drinking water treatment plant

Performance evaluation of nanofiltration membranes for SWRO brine valorisation: Insights from a pilot plant under real conditions

Comparison of nanofiltration and reverse osmosis membrane technologies in the advanced treatment of printing and dyeing wastewater

Pilot Study on the Combination of Different Pre-Treatments with Nanofiltration for Efficiently Restraining Membrane Fouling While Providing High-Quality Drinking Water

Evaluation of the nanofiltration of brines from seawater desalination plants as pre-treatment in a multimineral brine extraction process

Pilot-scale fabrication of nanofiltration membranes and spiral-wound modules

Reclamation of impacted urban phreatic water through nanofiltration technology: Insight on natural organic matter removal by fluorescence spectroscopy

Application and environmental impact of loose nanofiltration in surface water treatment

Performance of Nanofiltration for Improving the Drinking Water Quality in a Water Supply Plant with Micropolluted Water Resource

Membrane fouling control and contaminant removal during direct nanofiltration of surface water

Nanofiltration in Pilot Scale for Wastewater Reclamation: Long-term Performance and Membrane Biofouling Characteristics

Enhancing membrane separation performance in the conditions of different water electrical conductivity and fouling types via surface grafting modification of a nanofiltration membrane, NF90

Gravity-driven ultrafiltration and nanofiltration recycled membranes for tertiary treatment of urban wastewater

Nanofiltration hollow fiber membranes for textile wastewater treatment: Lab-scale and pilot-scale studies

Enhancing nanofiltration membrane selectivity between mineral salts and organic pollutants by sulfonic acid functionalization for drinking water treatment

Preparation of Nanofiltration Membranes for High Rejection of Organic Micropollutants and Low Rejection of Divalent Cations

Effect of Varying Piperazine Concentration and Post-Modification on Prepared Nanofiltration Membranes in Selectively Rejecting Organic Micropollutants and Salts

Enhancement of the natural organic matter removal from drinking water by nanofiltration

Rejection of malathion by nanofiltration and reverse osmosis membranes exposed to foulant and two clean-in-place procedures

Membrane filtration technologies applied to municipal secondary effluents for potential reuse