Abstract:Thin film silicon solar cells are believed to be promising candidates for continuing cost reduction in photovoltaic panels because silicon usage could be greatly reduced. Since silicon is an indirect bandgap semiconductor, its absorption coefficient is low for photons in the wavelength ranges between 600nm and 1100nm. For high efficiency thin film modules, effective light trapping is essential. Traditional schemes such as textured transparent conductive oxide (TCO) and metal reflector have several disadvantages such as enhanced surface recombination, parasitic losses at the TCO/metal interface, and the lack of ability to control and optimize the textured surface. We have previously proposed to employ a light trapping structure, which combines a self-assembled submicron grating and a distributed Bragg reflector (DBR) on the backside of thin film silicon solar cells. The DBR works as a one-dimensional photonic crystal to obtain almost 100% reflectivity. The grating scatters the incident light into oblique angles to significantly enhance the optical path length. Numerical calculations predict that by optimizing the feature sizes of the grating and DBR, up to 31% relative efficiency increase can be obtained, compared to the bare thin film Si. By using self-assembly, the organized grating structure can be formed spontaneously at a much lower cost. Current-voltage relations and quantum efficiency measurements were taken to verify the performance of our designed back structure. In the wavelength range of 600-900nm, photon absorption is greatly enhanced. As a result, more than 20% relative efficiency enhancement is achieved for 1.5um thin film silicon cells. These numerical and experimental results show that a light trapping design can be low-cost and increase efficiencies for high performance thin film Si solar cells.

Effects of One-Dimensional Photonic Crystal on Thin Film Silicon Solar Cells

Design and analysis of one-dimensional nanostructure on amorphous silicon solar cell for surface reflectance reduction

Silicon Rich Carbide As A Conductive Substrate For Si Qd Solar Cells

Impact of one-dimensional photonic crystal back reflector in thin-film c-Si solar cells on efficiency

Improved Nanocrystal Formation, Quantum Confinement and Carrier Transport Properties of Doped Si Quantum Dot Superlattices for Third Generation Photovoltaics

Improving thin-film crystalline silicon solar cell efficiencies with photonic crystals

Photonic Crystal Structures for Light Trapping in Thin-Film Si Solar Cells: Modeling, Process and Optimizations

Thin-film silicon solar cells: photonic design, process and fundamentals

Effects of frequency upconversion layer and two-dimensional arrays of inverted nanocone hole on the performance of ultrathin crystalline silicon solar cells

Thin Film Silicon Solar Cell Design Based On Photonic Crystal And Diffractive Grating Structures

Efficient Light Trapping Structure in Thin Film Silicon Solar Cells

Electro-Optical Simulation Of In Ultra-Thin Photonic Crystal Amorphous Silicon Solar Cells

Progress in thin-film silicon solar cells based on photonic-crystal structures

Absorption enhancement using photonic crystals for silicon thin film solar cells

Development of the Monolayer Silicon Solar Cell Based on Photonic Crystals

Theoretical analysis of performance improvement of thin film solar cells with two-dimensional photonic crystals and distributed Bragg reflector textured structures

Integrated Photonic Structures For Light Trapping In Thin-Film Si Solar Cells

Low-cost, Deterministic Quasi-periodic Photonic Structures for light trapping in thin film silicon solar cells

Nanoimprint Photonic Crystal Film Enhanced Light-Trapping in a-Si Thin Film Solar Cells

Enhanced Light Absorption of Ultrathin Crystalline Silicon Solar Cells Via the Design of Front Nanostructured Silicon Nitride

An Investigation on a Crystalline-Silicon Solar Cell with Black Silicon Layer at the Rear.