Abstract:Despite chemical vapor transport (CVT) being a widely used method for crystal growth of inorganic substances, detailed mechanistic studies on the course of the crystallization process are rather few. In this study, an elaborated experimental screening run combined with sophisticated modeling of the respective heterogeneous equilibria is presented: Crystal growth of germanium by vapor transport with the addition of iodine has been chosen as a model system for validation of the applied method spectrum. In order to record the course and the interplay of heterogeneous equilibrium and nonequilibrium reactions in the system Ge–I, the experimental setup of high-temperature gas-balance (HTGB) is applied. Additionally, the observed evaporation processes are compared with saturation curves of corresponding volatile substances and, thus, can be assigned to individual species within the system. In this experimental screening, a phase sequence means to examine how the condensed phases undergo iodine depletion and how the gaseous phase undergoes a germanium enrichment when the temperature is increased. This phase screening combined with annealing experiments in the course of the phase sequence helps to analyze stepwise nonequilibrium products and to identify the characteristic species. Subsequently, for the evaluation of the composition of the gaseous phase, and for the deduction of the vapor transport mechanism, thermodynamic modeling by the CalPhaD method is performed. For the reference system, it is confirmed that iodine does not act as the transport agent. Instead, GeI4 is responsible for the volatilization of germanium, forming GeI2. Nevertheless, investigations clearly illustrate how GeI4 forms naturally in the phase sequence in the system Ge–I, which makes direct addition of it unnecessary. The recommended temperature range for vapor transport of germanium spans from 460 to 800 °C. Modeling shows that migration rates for germanium reaches a maximum at a mean temperature between 540 and 550 °C. Finally, vapor transport experiments were performed from 565 to 515 °C and from 690 to 590 °C. By increasing the deposition temperature, a slight decrease of the migration rate was observed, though a positive impact on the crystal's morphology was also found.The Supporting Information is available free of charge at <a class="ext-link" href="/doi/10.1021/acs.cgd.0c00679?goto=supporting-info">https://pubs.acs.org/doi/10.1021/acs.cgd.0c00679</a>.Collection of thermodynamic data used for modeling, complete temperature programs for vapor transport experiments (<a class="ext-link" href="/doi/suppl/10.1021/acs.cgd.0c00679/suppl_file/cg0c00679_si_001.pdf">PDF</a>)This article has not yet been cited by other publications.

Crystal Growth Via the Gas Phase by Chemical Vapor Transport Reactions

Crystal Growth by Chemical Vapor Transport: Process Screening by Complementary Modeling and Experiment

Growth of pure and intercalated ZrTe2, TiTe2 and HfTe2 dichalcogenide single crystals by isothermal chemical vapor transport

Gas-pressure chemical vapor transport growth of millimeter-sized c-BAs single crystals with moderate thermal conductivity

Chemical Vapor Deposition of Elemental Crystallogen Thin Films

Vapor Growth of III Nitrides

Chemical transport reactions in gases and some remarks concerning melts and fluid phases

Seeded Growth Of High-Quality Transition Metal Dichalcogenide Single Crystals Via Chemical Vapor Transport

Growth of Silicon Carbide Bulk Crystals by Physical Vapor Transport Method and Modeling Efforts in the Process Optimization

Growth Mode Control of Large Size ZnO Single Crystal Growth Through Chemical Vapor Transport

Modeling of Diffusion for Crystal Growth

Facile High-Yield Growth of One-Dimensional van der Waals Ta 2 Pd 3 Se 8 via Chemical Vapor Transport Using PdCl 2 as a Transport Agent

Synthesis of large single crystals of a clathrate compound MTN (a zeolite-like material) by the vapor-phase method

Crystal growth rates in supercooled atomic liquid mixtures

Isotropic and Anisotropic Growth Models for the Sublimation Vapour Transport Process

Single crystal growth by the traveling solvent technique: A review

Two‐Dimensional Semiconductors Grown by Chemical Vapor Transport

Phase-field crystal model with a vapor phase

Modeling of Gas Phase and Surface Reactions in an Aluminum Nitride Growth System

Numerical Simulation of the Transport of Gas Species in the PVT Growth of Single‐Crystal SiC

A computer simulation of crystal growth by the traveling-solvent method (TSM): pseudo-steady-state calculations