Abstract:Methane pyrolysis is a transitional technology for environmentally benign hydrogen production with zero greenhouse gas emissions, especially when concentrated solar energy is the heating source for supplying high-temperature process heat. This study is focused on solar methane pyrolysis as an attractive decarbonization process to produce both hydrogen gas and solid carbon with zero CO2 emissions. Direct normal irradiance (DNI) variations arising from inherent solar resource variability (clouds, fog, day-night cycle, etc.) generally hinder continuity and stability of the solar process. Therefore, a novel hybrid solar/electric reactor was designed at PROMES-CNRS laboratory to cope with DNI variations. Such a design features electric heating when the DNI is low and can potentially boost the thermochemical performance of the process when coupled solar/electric heating is applied thanks to an enlarged heated zone. Computational fluid dynamics (CFD) simulations through ANSYS Fluent were performed to investigate the performance of this reactor under different operating conditions. More particularly, the influence of various process parameters including temperature, gas residence time, methane dilution, and hybridization on the methane conversion was assessed. The model combined fluid flow hydrodynamics and heat and mass transfer coupled with gas-phase pyrolysis reactions. Increasing the heating temperature was found to boost methane conversion (91% at 1473 K against ~100% at 1573 K for a coupled solar-electric heating). The increase of inlet gas flow rate Q0 lowered methane conversion since it affected the gas space-time (91% at Q0 = 0.42 NL/min vs. 67% at Q0 = 0.84 NL/min). A coupled heating also resulted in significantly better performance than with only electric heating, because it broadened the hot zone (91% vs. 75% methane conversion for coupled heating and only electric heating, respectively). The model was further validated with experimental results of methane pyrolysis. This study demonstrates the potential of the hybrid reactor for solar-driven methane pyrolysis as a promising route toward clean hydrogen and carbon production and further highlights the role of key parameters to improve the process performance.

Combined Ceria Reduction and Methane Reforming in a Solar-Driven Particle-Transport Reactor

A solar methane reforming reactor design with enhanced efficiency

Experimental and Simulation Study of Mn–Fe Particles in a Controllable-Flow Particle Solar Receiver for High-Temperature Thermochemical Energy Storage

Steam methane reforming over structured reactors under concentrated solar irradiation

A New Reactor Concept for Efficient Solar-Thermochemical Fuel Production

Enhanced Solar-to-Fuel Efficiency of Ceria-Based Thermochemical Cycles via Integrated Electrochemical Oxygen Pumping

Experimental study of a high-temperature porous-medium filled solar thermochemical reactor for CO production

Thermochemical energy storage analysis of solar driven carbon dioxide reforming of methane in SiC-foam cavity reactor

A Pressurized High-Flux Solar Reactor for the Thermochemical Gasification of Charcoal Slurry—Two-Phase Flow and Heat Transfer Analysis

Thermal and chemical analysis of methane dry reforming in a volumetric reactor under highly concentrated solar radiation

Extraction of Hydrogen from Water Using CeO2 in a Solar Reactor Using a Concentrated Flux of Solar Radiation

Thermodynamic analysis of a synergistic integration of solid oxide fuel cell and solar-based chemical looping methane reforming unit for solar energy storage, power production, and carbon capture

Design and optimization of a solar-driven methane dry reforming reactor by developing an optical-thermal-chemical model

Thermodynamic Analysis of a Conceptual Fixed-Bed Solar Thermochemical Cavity Receiver–Reactor Array for Water Splitting Via Ceria Redox Cycling

Multi-field coupling and collaborative optimization design of the solar thermochemical cycle process based on ceria

Post-combustion emission control of a gas turbine cooperated solar assisted CO2 based-reforming utilizing CO2 capture technology

CFD Simulation of a Hybrid Solar/Electric Reactor for Hydrogen and Carbon Production from Methane Cracking

Performance optimization of a cavity type concentrated solar reactor for methane dry reforming reaction with coupled optics-CFD modeling

Thermochemical CO2 reduction over NiFe2O4@alumina filled reactor heated by high-flux solar simulator

Energy storage efficiency optimization of methane reforming with CO2 reactors for solar thermochemical energy storage☆

Rh/Al Nanoantenna Photothermal Catalyst for Wide-Spectrum Solar-Driven CO2 Methanation with Nearly 100% Selectivity