Abstract:The mechanism of convective drying of single coarse lignite particles has important theoretical and practical significance for the development of the lignite drying technologies. The drying kinetics of single lignite particles in hot air were investigated experimentally with particles diameters of 20 and 30 mm. The experiments were performed at hot air velocities of 0.7 and 1.5 m/s and hot air temperatures of 100 and 140 °C. The results from these experiments show that the lignite particle size, the hot air temperature, and the velocity all significantly influence the drying. For the range of operating conditions investigated in this study, the drying time was reduced by increasing the temperature and velocity of the hot air flow and decreasing the particle size. The constant drying rate period was not obvious with the lignite characterized by a long decreasing drying rate. Both types of lignite had a good linear relationship between the drying rate and the dry-basis moisture content. A mathematical model for the drying of single particles was developed assuming local thermodynamic equilibrium to describe the multiphase flow in the porous particle with the energy and mass conservation equations to describe the heat and mass transfer during the drying. The drying model included convection of the free water, diffusion of the bound water, and convection and diffusion of the gas mixture in the lignite particle. The numerical results agree well with the experimental data verifying that the mathematical model can evaluate the drying performance of porous lignite particles. The effects of the drying conditions such as the particle size, the temperature, the absolute humidity, and the velocity of the drying air on the drying process were evaluated using the numerical model.

Superheated Steam Drying of Solid Fuels: Wood Biomass and Lignite

Fluidized Bed Drying and Devolatilization of Lignite Washery Tailing Particles: Experiments and Modeling

An experimental verification of numerical model on superheated steam drying of Belchatow lignite

Performance analysis of a novel biomass-fired grain dryer integrated with thermal storage medium

Newly designed superheated steam dryer bearing heat recovery unit: Analysis of energy efficiency and kinetics of Kelp drying

Superheated steam drying and its applicability for various types of the dryer: The state of art

Kinetics of Sludge Superheated Steam Drying and Optimization of Process Parameters

Low-Pressure Superheated Steam Drying—Vacuum Drying of a Porous Media and the Inversion Temperature

Modeling moisture and heat transfer during superheated steam wood drying considering potential evaporation interface migration

Superheated Steam Spray Drying as an Energy-Saving Drying Technique: A Review

APPLICATION OF THE DRYING MECHANISM OF POROUS MEDIA IN THE THERMAL DEHYDRATION FOR LIGNITE

Drying, Re-Adsorption Characteristics, and Combustion Kinetics of Xilingol Lignite in Different Atmospheres

Enhanced water removal from low-rank coal via flash evaporation: Insights into dewatering performance, upgrading effects, and energy analysis

Superheated steam drying of single wood particles: A characteristic drying curve model deduced from continuum model simulations and assessed by experiments

Experimental and Numerical Investigation of Convective Drying of Single Coarse Lignite Particles

Superheated Steam Dryer application for drying of sticky and pastry materials – particluar referens to distillers wet grain and solubles (DWGS)

Evaluation of a biomass drying process using waste heat from process industries: A case study

A green and efficient lignite-fired power generation process based on superheated-steam-dried open pulverizing system

Iterative method for fast estimation of convective drying characteristics of biomass

Superheated steam as carrier gas and the sole heat source to enhance biomass torrefaction

Thermal dehydration of urban biosolids with green liquor dregs from pulp and paper mill