Abstract:Fabrication of nano-crystalline thin film solar cell by co-sputtering of silicon and aluminum, and metal induced crystallization is reported in this paper. After a brief introduction on magnetron sputtering and aluminum induced crystallization techniques, it discusses the drawbacks of "aluminum induced layer exchange" concept as the common method for fabricating poly-Si thin films; and proposes Si-Al co-sputtering as a simple alternative fabrication method. Then a three-steps process is introduced for the fabrication of "Al electrode/n-Si wafer/p-Si thin film/Al electrode" solar cell. Material and electrical characterizations of the fabricated p-Si thin films are done by Raman spectroscopy, X-ray diffraction, optical microscopy, scanning electron microscopy and Hall Effect measurement to study the crystallization ratio, grain size, morphology, carrier density and mobility of the prepared films, respectively. The best fabricated samples show a crystallization ratio of 88% and the largest grain size of 68 nm. The hole concentration in the films is in the order of 10(18) to 10(19) cm(-1) with a maximum mobility value of 17 cm(2)/V s. Then, photovoltaic properties of the fabricated solar cells are determined by under dark and illumination J-V curves, and external quantum efficiency measurements. Dark J-V curve of the best sample represents an ideality factor of 1.39, rectification ratio of 1993 at 1 V and reverse saturation current density of 62.1 nA/cm(2) which confirms the formation of a good p-n junction. The illuminated J-V curve under AM1.5G conditions exhibits a photovoltaic conversion efficiency of 6.02% for the best sample, with a short circuit current density of 24.9 mA/cm(2) and open circuit voltage of 456 mV. The external quantum efficiency of this sample reaches to more than 59% at the wavelength of 700 nm. Finally, a simple model is proposed to describe the formation of nano-crystalline Si thin film, deposited by Si-Al co-sputtering, during the thermal annealing.

Increasing the Silicon Solar Cell Efficiency with Nanostructured SnO2 Anti-reflecting Coating Films

Improved Efficiency of Solar Cell using Silane based SnO2 Thin Films with Self-Cleaning and Antifogging Properties

Synthesis and Characterization of Al-doped NiO Nanostructured Thin Films Elaborated by Solar Spray Pyrolysis Technique, for Photovoltaic Cells

Synthesis and Characterization of Fe, Cu, and Cr Doped ZnO Nanocrystallite Films and the Effects on Passivation of Silicon Surface

Nanowire-based multifunctional antireflection coatings for solar cells

Significant advancements in passivating crystalline silicon surfaces achieved through the implementation of metal-doped zinc oxide layers

Enhancing the Performance of Nanocrystalline SnO2 for Solar Cells through Photonic Curing Using Impedance Spectroscopy Analysis

Enhanced optical performance of solar cell using hydrophobic SnO2/TEOS/MTMS antireflection coating

Enhanced Electrical Properties of Crystalline Silicon Solar Cells via Nano-Composite Polyvinyl-Alcohol/Titanium Dioxide

Optimizing thin-film silicon solar cells with nanostructured TiO2 and a silver back reflector for enhanced energy conversion efficiency

Surface Passivation of Crystalline Silicon Solar Cells by Cr:ZnO Coating Layers

Facial Synthesis of SnO2 Nanoparticle Film for Efficient Fiber-Shaped Dye-Sensitized Solar Cells

Nano-crystalline Thin Films Fabricated by Si-Al Co-Sputtering and Metal Induced Crystallization for Photovoltaic Applications

Light Scattering by Textured Al-Doped Zinc Oxide Film for Thin Film Silicon Solar Cells Coated on Glass Substrates

Bifunctional Surface Engineering on SnO 2 Reduces Energy Loss in Perovskite Solar Cells

An Extended Approach on Power Conversion Efficiency Enhancement Through Deposition of ZnS-Al2S3 Blends on Silicon Solar Cells

Hydrophobic nickel doped Co3O4 sprayed thin films as solar absorber

Growth rate of AL2O3 Thin Film by Liquid Phase Deposition as an Anti-reflection Coating Layer on Crystalline Silicon for Solar Cell Applications

Conductive and optically transparent sol–gel spin coated Al3+ and Sn4+ doped ZnO nano-crystalline thin-films

Facilitating Electron Transport in Perovskite Solar Cells through Tailored SnO2 Film Composition

Sputtered AZO Thin Films for TCO and Back Reflector Applications in Improving the Efficiency of Thin Film a-Si:H Solar Cells