Abstract:In this paper, the processing parameters of growing GaN epilayer by hydride vapor phase epitaxy are optimized The influences of the low-temperature (LT) nucleation layer growth time, WM precursor ratio and the growth temperature on GaN layer are investigated by the high-resolution X-ray diffraction (HRXRD) signature for the asymmetric and symmetric reflections. The investigation finds that the LT-nucleation layer not only supplies the nucleation centers having good crystal quality, but also promotes the lateral growth of the sequent high temperature (HT) growth. The optimal LT nucleation layer growth time, WEI precursor ratio and the growth temperature can effectively enhance lateral growth to reduce the crystal defects and are favorable to converting the growth mechanism from threedimension to two-dimension in HT growth. The structural and optoelectronic properties of the as-grown GaN layer with a thickness of 15 um at the optimal parameters are studied by scanning electron microcopy, atomic force microscopy (AFM), HRXRD, Raman spectra, and photoluminescence (PL) measurements. X-ray rocking curves show that the full widths at half maximum of (002) and (102) are 317 and 343 arcsec, respectively. The surface roughness (rms: root mean square) is 0.334 nm detected using AFM. These characteristics show that the sample has good lattice quality and smooth surface morphology. In PL spectrum, the near band edge emission is dominated by emission from excitons bound to neutral donors (D X) near 3.478 eV with 11 meV blue-shift and the yellow band emission is very weak. The results indicate that the GaN layer has good crystal quality and excellent optoelectronic properties, but a little biaxial in-plane compressive strain also exists in it due to the lattice and thermal mismatch.

Significantly improved surface morphology of N-polar GaN film grown on SiC substrate by the optimization of V/III ratio

Performance enhancement of InGaN/GaN MQWs grown on SiC substrate with sputtered AlN nucleation layer

Enhancing two-dimensional growth of high-temperature AlN buffer to improve the quality of GaN on Si grown by ex situ two-step method

Improvements in characteristics of N-polar Si-doped AlGaN epi-layer grown on mis-oriented c-plane sapphire substrate

Improvement in Structural and Electrical Characteristics of Nonpolar A-Plane Si-doped N-Algan

The Influence of V/III Ratio on GaN Grown on Patterned Sapphire Substrate with Low Temperature AlN Buffer Layer by Hydride Vapor Phase Epitaxy

Influences of nitridation treatment on the properties of semi-polar (11 2 ̅2) plane AlGaN films

Highly Conductive n-Al0.65Ga0.35N Grown by MOCVD Using Low V/III Ratio

Improved semipolar green InGaN/GaN quantum wells on asymmetrically grown (11(2)over-bar2) GaN templates and their correlations

Epitaxial growth of semi-polar (11–22) plane AlInGaN quaternary alloys on m-plane (10-10) sapphire substrates

Light Output Enhancement of GaN-Based Light-Emitting Diodes Based on AlN/GaN Distributed Bragg Reflectors Grown on Si (111) Substrates

Suppressing the zincblende-phase inclusions in nitrogen-polar wurtzite-phase InGaN films by pulsed metalorganic chemical vapor deposition

Effect of growth temperature and V/III-ratio on the surface morphology of MOVPE-grown cubic zincblende GaN

Effects of V/III Ratio on the Growth of a -Plane GaN Films

Growth of III-Nitride Materials and Blue Light-Emitting Diodes by Metal Organic Vapor Phase Epitaxy

Effects of V/III ratio on species diffusion anisotropy in the MOCVD growth of non-polar α-plane GaN films

Enhanced performance of (112 ̄2) plane p-AlGaN grown with indium surfactant

Achievement of Polarity Reversion from Al(Ga)-polar to N-polar for AlGaN Film on AlN Seeding Layer Grown by a Novel Flow‐modulation Technology

Optimization of the Parameters for Growth High-Qulity Gan Film by Hydride Vapor Phase Epitaxy

The role of AlN thickness in MOCVD growth of N-polar GaN

Impact of ITO Layer on the Spatial Optical Distribution of Semipolar (20-21) InGaN/GaN Multiple Quantum Wells with Surface Morphology.