Abstract:The advantages and drawbacks of existing wet chemical phosphorus (P) recovery technologies, their applicability to different types of sewage sludge ash (SSA) and the role of the decay products of detergent zeolites as a source of reactive Al in SSA are analyzed. Since neither a purely acidic nor a purely alkaline treatment are able to provide satisfactory technical solutions a wet chemical phosphorus (P) recovery process for sewage sludge ashes (SSAs) is investigated in detail that is based on a sequential treatment of SSA with an acid and a base. As a result of an acidic pre-treatment, the P fraction of the raw SSA that was bound as - alkaline-insoluble - calcium phosphate (Ca-P) is converted into aluminum phosphate (Al-P). This newly formed Al-P can be easily dissolved via alkaline treatment and then easily separated from the alkaline leachate via precipitation of Ca-P. The Al-component can be reused as precipitant for P-removal in waste water treatment plants (WWTPs). The investigated process requires fewer chemicals than the direct acidic dissolution of all P-compounds contained in the SSA. This is due to the described rearrangement of the P component from Ca-P to Al-P. That such a rearrangement of P occurs indeed was confirmed through a combination of XRD, ICP and XRF analyses together with mass balance calculations. The present investigation proves that the process works for very different types of SSAs: For Al-rich SSAs that come from WWTPs where Al-salt is used for chemical P-removal the described sequential treatment process works best and yields P-recovery rates as high as 70-77%. But even for SSAs from WWTPs where only iron salt is used for chemical P-removal, a considerable amount of the reactive Al necessary for the described P-rearrangement is supplied by decay products of detergent zeolites, a hidden Al-source present in most SSAs produced in Europe.

Phosphorus Recovery from Sewage Sludge Ash: A Case Study in Gifu, Japan

Development of a novel phosphorus recovery system using incinerated sewage sludge ash (ISSA) and phosphorus-selective adsorbent

Phosphorus (P) recovery and reuse as fertilizer from incinerated sewage sludge ash (ISSA)

Feasibility of wet-extraction of phosphorus from incinerated sewage sludge ash (ISSA) for phosphate fertilizer production: A critical review

Selective Recovery of Phosphorus from the Leachate of Incinerated Sewage Sludge Ash Using the Zr-modified Acid-Leaching Residue As Adsorbent for Two-Fold Resource Utilization

Phosphorus recovery through biologically induced precipitation by partial nitritation-anammox granular biomass

Efficient and Selective Recovery of Iron Phosphate from the Leachate of Incinerated Sewage Sludge Ash by Thermally Induced Precipitation

Simultaneous phosphorus and amorphous silica recovery from incinerated sewage sludge ash

Recovery of ammonia through struvite production using anaerobic digestate of piggery wastewater and leachate of sewage sludge ash

On wet chemical phosphorus recovery from sewage sludge ash by acidic or alkaline leaching and an optimized combination of both

Phosphate recovery from sludge-incinerated ash by adsorption with hydrotalcite synthesized by metals in the ash

A comparison between sulfuric acid and oxalic acid leaching with subsequent purification and precipitation for phosphorus recovery from sewage sludge incineration ash

Efficient recovery of phosphorus in sewage sludge through hydroxylapatite enhancement formation aided by calcium-based additives

Phosphorus recovery from calcium phosphate enriched activated sludge

Phosphorus recovery from sludge by pH enhanced anaerobic fermentation and vivianite crystallization

Sequencing biological acidification of waste-activated sludge aiming to optimize phosphorus dissolution and recovery

Hydroxyapatite crystallization-based phosphorus recovery coupling with the nitrogen removal through partial nitritation/anammox in a single reactor

Phosphorus recovery from the wastewater stream—necessity and possibilities

Phosphorus recovery from municipal sludge-derived ash and hydrochar through wet-chemical technology: A review towards sustainable waste management

Targeting Phosphorus Transformation to Hydroxyapatite Through Sewage Sludge Pyrolysis Boosted by Quicklime Toward Phosphorus Fertilizer Alternative with Toxic Metals Compromised

Phosphate recovery from swine wastewater using plant ash in chemical crystallization