Abstract:Globally, Brazil and United States (US) have the large-scale programs of biofuels production. Among other parameters, the feasibility and sustainability of petroleum-based fuels by biofuels replacement depend upon the proper nitrogen (N) fertilizers usage as well as the associated nitrous oxide (N2O) emissions along the production chain. The efficiency of N use also depends on the choice of biofuel crop. Previous studies indicated that sugarcane (Saccharum spp.) requires less N than corn (Zea mays L), thus, the hypothesis tested was that Brazilian sugarcane-based ethanol requires less synthetic N inputs per unit produced than corn-based ethanol in the US. Consequently, ethanol production in Brazil from sugarcane has lower N2O emissions associated with N fertilization than ethanol produced in the US from corn. Here, we reviewed national-scale dataset on sugarcane and corn cultivation in Brazil and US respectively, in order to compare temporal changes in the cultivated area for both crops (devoted for ethanol production), N-fertilizers consumption, and associated emission of N2O in the period 2000–2020. The same parameters were forecasted for the upcoming decade. For both periods, there were calculated two indexes: the N-fertilizer consumption index (the quotient of N-fertilizer input by ethanol production) and the N2O emission index (the quotient of N-fertilizer input by N2O emission). In the period 2000–2020, the devoted area for sugarcane and corn cultivation increased around 43 and 9%, respectively, while the N rates recorded in 2020 for sugarcane in Brazil and corn in the US averaged, respectively, 78 and 167 kg ha−1 N. Moreover, within the 2000–2020 period, the average yield was 74 Mg ha−1 for sugarcane (stalks) in Brazil and 9.6 Mg ha−1 for corn (grain) in the US, which resulted in ethanol yield (in area basis) of 6009 and 4003 L ha−1, respectively. Thus, the N-fertilizer consumption index was much lower for sugarcane-based ethanol than for corn-based ethanol (0.009 versus 0.04 kg N L−1). Through the Intergovernmental Panel on Climate Change (IPCC) emission factor (Tier 1), we estimated that N2O emission is 4.6 times lower for sugarcane-based ethanol than for corn-based ethanol (94 versus 433 mg N2O per L−1). By 2030, ethanol production might reach 45 and 58 billion L in Brazil and within the US, respectively, leading to 0.45 and 2.07 million t of N-fertilizer consumption per year−1 for sugarcane and corn respectively. The outcomes herein endorse the sustainability of sugarcane as a feedstock for ethanol production and may guide stakeholders to establish public policies to enable sugarcane-based ethanol production as one alternative to tackle global warming and climate changes.

Incorporating Sub‐National Brazilian Agricultural Production and Land‐Use into U.S. Biofuel Policy Evaluation

Use of U.S. Croplands for Biofuels Increases Greenhouse Gases Through Emissions from Land-Use Change

Life-Cycle Energy Use and Greenhouse Gas Emission Implications of Brazilian Sugarcane Ethanol Simulated with the Greet Model

Nitrogen fertilizer consumption and nitrous oxide emissions associated with ethanol production – A national-scale comparison between Brazilian sugarcane and corn in the United States

Supplying the ethanol demand for 2030 in Brazil as a land-based climate change mitigation alternative: Implications on greenhouse gases emissions

How to Measure Greenhouse Gas Emissions by Fuel Type for Binary Sustainability Standards: Average or Marginal Emissions? An Example of Fertilizer Use and Corn Ethanol

Ethanol fuel in Brazil: policies and carbon emission avoidance

Infield greenhouse gas emissions from sugarcane soils in Brazil: effects from synthetic and organic fertilizer application and crop trash accumulation

Influence of spatially dependent, modeled soil carbon emission factors on life‐cycle greenhouse gas emissions of corn and cellulosic ethanol

Economic Assessment of Producing Corn and Cellulosic Ethanol Mandate on Agricultural Producers and Consumers in the United States

Reducing US Biofuels Requirements Mitigates Short-term Impacts of Global Population and Income Growth on Agricultural Environmental Outcomes

The impact of land‐use change emissions on the potential of bioenergy as climate change mitigation option for a Brazilian low‐carbon energy system

A review of domestic land use change attributable to U.S. biofuel policy

Land usage attributed to corn ethanol production in the United States: sensitivity to technological advances in corn grain yield, ethanol conversion, and co-product utilization

Evaluating the New ORDHIDEE-GM (grassland Management) Model to Tropical Area in Brazil.

Investigating Impacts of Alternative Crop Market Scenarios on Land Use Change with an Agent-Based Model

Bio-energy and CO2 emission reductions: an integrated land-use and energy sector perspective

Supply Chain Optimization of Sugarcane First Generation and Eucalyptus Second Generation Ethanol Production in Brazil

Effects of Ethanol Plant Proximity and Crop Prices on Land‐Use Change in the United States

Understanding the evolution of environmental and energy performance of the US corn ethanol industry: evaluation of selected metrics