Abstract:In this study, the effect of the cell density of monolithic catalysts was investigated and further mathematically modeled on cordierite supports used in CO 2 methanation. Commercial cordierite monoliths with 200, 400, and 500 cpsi cell densities were coated by immersion into an ethanolic suspension of Ni/CeO 2 active phase. SEM–EDS analysis confirmed that, owing to the low porosity of cordierite (surface area < 1 m 2 g −1 ), the Ni/CeO 2 diffusion into the walls was limited, especially in the case of low and intermediate cell density monoliths; thus, active phase was predominantly loaded onto the channels' external surface. Nevertheless, despite the larger exposed surface area in the monolith with high cell density, which would allow for better distribution and accessibility of Ni/CeO 2 , its higher macro-pore volume resulted in some introduction of the active phase into the walls. As a result, the catalytic evaluation showed that it was more influenced by increments in volumetric flow rates. The low cell density monolith displayed diffusional control at flow rates below 500 mL min −1 . In contrast, intermediate and high cell density monoliths presented this behavior up to 300 mL min −1 . These findings suggest that the interaction reactants-catalyst is considerably more affected by a forced non-uniform flow when increasing the injection rate. This condition reduced the transport of reactants and products within the catalyst channels and, in turn, increased the minimum temperature required for the reaction. Moreover, a slight diminution of selectivity to CH 4 was observed and ascribed to the possible formation of hot spots that activate the reverse water–gas shift reaction. Finally, a mathematical model based on fundamental momentum and mass transfer equations coupled with the kinetics of CO 2 methanation was successfully derived and solved to analyze the fluid dynamics of the monolithic support. The results showed a radial profile with maximum fluid velocity located at the center of the channel. A reactive zone close to the inlet was obtained, and maximum methane production (4.5 mol m −3 ) throughout the monolith was attained at 350 °C. Then, linear streamlines of the chemical species were developed along the channel.

Kinetic study of carbon monoxide methanation over mesoporous Ni-Mo catalyst prepared by a hydrothermal method

Engineering MOx/Ni Inverse Catalysts for Low-Temperature CO2 Activation with High Methane Yields

Intrinsic kinetics of CO2 methanation on low-loaded Ni/Al2O3 catalyst: Mechanism, model discrimination and parameter estimation

MoOx-Doped Ordered Mesoporous Ni/Al2O3 Catalyst for CO Methanation

Reaction Characteristics of Ni-Based Catalyst Supported by Al2O3 in a Fluidized Bed for CO2 Methanation

Catalytic Performance for CO Methanation over Ni/MCM-41 Catalyst in a Slurry-Bed Reactor

Modeling and experimental analysis of CO2 methanation reaction using Ni/CeO2 monolithic catalyst

Organic Additive Assisted Ordered Mesoporous Ni/Al2O3 Catalyst for CO2 Methanation

Intrinsic Kinetics of Methanol Synthesis over a New Catalyst

Kinetic and Spectroscopic Study of Methane Combustion over Α-Mn2o3 Nanocrystal Catalysts

The Catalytic Methanation of Coke Oven Gas over Ni-Ce/Al2O3 Catalysts Prepared by Microwave Heating: Effect of Amorphous NiO Formation

CO2 Methanation over Ni/Mg@MCM-41 Prepared by In-Situ Synthesis Method

Efficient and Stable Ni/ZSM-5@MCM-41 Catalyst for CO 2 Methanation

Ni Based Catalyst Supported on KIT-6 Silica for CO Methanation: Confinement Effect of Three Dimensional Channel on NiO and Ni Particles

Performance of Ni/Si‐MCM‐41 catalysts in CO2 methanation

Study on Methanation Performance of Biomass Gasification Syngas Based on a Ni/Al2O3 Monolithic Catalyst

Hydrogenation of CO to methane over mesoporous nickel-iron-alumina xerogel nano-catalysts

A Study on CO2 Methanation and Steam Methane Reforming over Commercial Ni/Calcium Aluminate Catalysts

The Intrinsic Kinetics of Methane Steam Reforming over a Nickel-Based Catalyst in a Micro Fluidized Bed Reaction System

Effect of micropores on the structure and CO2 methanation performance of supported Ni/SiO2 catalyst

Theoretical study coupling DFT calculations and kMC simulation of CO methanation on Ni(111) and Ni 3 Fe(111)