Abstract:The stereo-vision methods have been developed and used for measuring the wing deformation while the aircraft is in flight. However, it is difficult to achieve accurate measurement in flight test since inevitable camera movements often occur due to elasticity in the camera support and the surrounding structure, especially during heavy turbulence and large maneuver flight. Any slight camera movements within a stereo-vision system can directly influence the calibrated extrinsic parameters, then decrease 3D reconstruction accuracy, and even cause the measurement to fail. This study proposes a method to correct the effect of the camera movements to enable accurate wing deformation measurement using a stereo-vision system. A reference coordinate system is established based on the control points to unify the changing camera coordinate system. A dynamic extrinsic parameters calibration algorithm is developed to estimate the instantaneous position and orientation of the stereo cameras. To verify the presented method, an experiment in which the stereo cameras occurring relative movement was performed. The results show that the proposed method has effectively corrected the effects of camera movements. Furthermore, the proposed method was applied to the practical wing deformation measurement of a UAV in fieldwork. The maximum error of length and displacement is less than 0.8 mm when the stereo cameras remained unchanged. The actual accuracy of the overall measurement system is about 0.01% of the observed area (e.g. 0.8 mm in 6 m scale) under the conditions of flat viewing angle and outdoor scenes. While camera movements occur during the test, the corrected RMS error of displacement is reduced to about 1.5 mm and has decreased by 50% compared with that before correction. The enhanced precision and robustness of wing deformation measurement are well realized by the proposed method of correcting camera movements.

Research on Measurement and Deformation of Flexible Wing Flapping Parameters

Experimental Study on Flexible Deformation of a Flapping Wing with a Rectangular Planform

Dynamic Deformation Measurement of Bionic Flapping-Wing Robot Based on Fiber Bragg Grating Array

A novel videogrammetry-based full-field dynamic deformation monitoring method for variable-sweep wings

Reconstructing full-field flapping wing dynamics from sparse measurements

Measurement on Camber Deformation of Wings of Free-flying Dragonflies and Beating-flying Dragonflies

Wing deformation measurement using the stereo-vision methods in the presence of camera movements

Kinematics, Deformation, and Aerodynamics of a Flexible Flapping Rotary Wing in Hovering Flight

The spatial-temporal effects of wing flexibility on aerodynamic performance of the flapping wing

Measuring the Camber Deformation of A Dragonfly Wing Using Projected Comb Fringe

Dynamic CFD/CSD Coupling Research for Flexible Micro Aircraft

Analysis of nonlinear aerodynamic performance and passive deformation of a flexible flapping wing in hover flight

Fluid-structure Analysis of Flapping-Wing Rotorcraft Considering Stiffness Influence

Force production and asymmetric deformation of a flexible flapping wing in forward flight

Monocular In-flight Measurement of Airfoil Deflections

Wing Deformation-Aware Vision-Based Airplane Attitude Measurement

Aerodynamic performance of flexible flapping wings deformed by slack angle

Research on Large-Deformation Trapezoidal Skin Structure of Morphing Wings

An experimental data-driven mass-spring model of flexible Calliphora wings

Measurement of wing motion, deformation, and inertial forces of a biomimetic butterfly

Optical Measurement of the Deformation, Motion, and Generated Force of the Wings of a Moth, Mythimna Separata (Walker).