Abstract:A combined steady-state and transient approach is employed to investigate the corrosion behavior of X80 pipeline steel in carbon dioxide-saturated brines. Continuous bubbling of carbon dioxide into a test vessel with 1 liter capacity is performed to simulate the flowing condition. The measurement of time-dependent open-circuit potential, polarization resistance, and electrochemical impedance spectroscopy (EIS) is conducted to interpret the evolution of dissolution processes at the corroding interface. Three distinguishing stages are observed at a temperature of 60 °C during a whole exposure of 144 h. Analyses mainly based on the consecutive mechanism show that after the first stage of the active-adsorption state, the anodic reaction is significantly retarded by the accumulation of (FeOH)ads on the iron surface, causing a sharp increase in the polarization resistance and the open-circuit potential, as well as the disappearance of the inductive loop in EIS. At the third stage, the formation of the corrosion product layer similarly reduces both the anodic and cathodic reactions, which arouses a linear increase in the polarization resistance with time and a capacitive loop in EIS but changes the open-circuit potential slightly. An increase in salinity in this study reduces the polarization resistance and enhances iron dissolution by promoting the formation and relaxation of (FeOH)ads; however, it brings little change to the developing time of the three stages obviously. At a low temperature of 20 °C, a protective product layer is not observed in carbon dioxide-saturated brine, and the dissolution of iron is mainly under activation control during the whole exposure. A notable enlarged polarization resistance and different interfacial processes are observed in an alkaline solution compared with those in acidic environments, which is deduced to be resulted from an impedance in the relaxation of (FeOH)ads by increasing pH. The observations in this study support well that the iron dissolution reaction at the initial stage exposed in carbon dioxide aqueous environments is dominant by water adsorption on the iron surface, and further investigation should be performed on the role that carbon dioxide plays in the evolution of corrosion products and the formation of a protective film on the steel surface by taking into account local water chemistry.

Effect of Alternating Current on Passive Film and Corrosion Behavior of Pipeline Steel with Different Microstructures in Carbonate/Bicarbonate Solution

The influence of half-cycle rectified sinusoidal alternating current (AC) on corrosion of X80 pipeline steel in an acid bicarbonate solution

Combined Effect of Alternating Current Interference and Cathodic Protection on Pitting Corrosion and Stress Corrosion Cracking Behavior of X70 Pipeline Steel in Near-Neutral pH Environment

Effect of pH value on corrosion of carbon steel under an applied alternating current

Effect of Microstructures on Corrosion of X80 Pipeline Steel in an Alkaline Soil

X80 Steel Corrosion Induced by Alternating Current in Water-Saturated Acidic Soil

Influence of Alternating Voltages on Passivation and Corrosion Properties of X80 Pipeline Steel in High Ph 0.5 Mol L− 1nahco3+0.25 Mol L− 1Na2co3solution

Effect of Alternating Voltage on Corrosion of X80 and X100 Steels in a Chloride Containing Solution – Investigated by AC Voltammetry Technique

The Influence of Microstructures on the Corrosion Properties of X80 Pipeline Steel in Near-Neutral Ph Soil

AC corrosion behavior and the effect of stone-hard-soil on corrosion process in the earth alkaline rich environment

Experimental Investigation on Corrosion Behavior of X80 Pipeline Steel under Carbon Dioxide Aqueous Conditions

Micro-electrochemical Characterization and Mott–Schottky Analysis of Corrosion of Welded X70 Pipeline Steel in Carbonate/bicarbonate Solution

Research on dynamic AC corrosion behavior of X65 Pipeline Steel under cathodic protection

Effects of alternating current on microbiologically synergistic corrosion of pipeline steel X80 applied by elastic stress

Experimental study on pipeline corrosion behavior coupled with microorganisms and dynamic alternating current interference

Influence of alternating current on corrosion behavior of X100 steel in Golmud soil simulated solution with different pH

Corrosion characteristics of simulated reheated heat-affected-zone of X80 pipeline steel in carbonate/bicarbonate solution

Electrochemical and Stress Corrosion Mechanism of Submarine Pipeline in Simulated Seawater in Presence of Different Alternating Current Densities

Stress corrosion cracking behavior of X80 pipeline steel under alternating current, Desulfovibrio desulfurican and cathodic protection potential

Galvanic Effect and Alternating Current Corrosion of Steel in Acidic Red Soil

Micro-Electrochemical Characterization of Corrosion of Pre-Cracked X70 Pipeline Steel in A Concentrated Carbonate/Bicarbonate Solution