Abstract:This study involves the deposition of magnesium-doped zinc oxide (MZO) thin films through radio frequency (RF) magnetron sputtering, followed by annealing at temperatures of 350 °C, 450 °C, and 550 °C. Since there is no significant impact of annealing temperatures on MZO thin films, MZO and aluminium-doped zinc oxide (AZO) were co-sputtered to deposit Al-doped MZO (AMZO) thin films. The grown AMZO films were subsequently annealed at 350 °C, 450 °C and 550 °C to regulate their microstructural and optoelectronic characteristics. The X-ray diffraction (XRD) analysis revealed that AMZO films exhibited a predominant (0 0 2) orientation with a single intense diffraction peak, showcasing a wurtzite structure. The field emission scanning electron microscopy (FESEM) presented an increment in grain size for MZO and AMZO films from 31.3 to 64.7 nm and 57.0 to 64.8 nm, respectively. Furthermore, the atomic force microscopy (AFM) analysis demonstrated a substantial reduction in surface roughness from 1.67 to 1.58 nm for AMZO films annealed at 550 °C compared to MZO films. Notably, the optical band gap changed from 3.64 to 3.32 eV, which was influenced by both the Al content and annealing temperature. The carrier concentration for as deposited and annealed MZO films remained in the orders of 10 14 cm -3 , whereas AMZO and AMZO films annealed at 550 °C exhibited higher carrier concentrations, in the orders of 10 16 cm -3 and 10 20 cm -3 , respectively. Remarkably, low resistivity (2.10 x 10 -2 Ω .cm) was observed for AMZO films annealed at 550 °C. Based on these findings, AMZO films exhibited prospect as high-resistivity transparent (HRT) layers for CdTe thin films solar cell applications.

Influence of hydrogen and oxygen on the structure and properties of sputtered magnesium zirconium oxynitride thin films

Effect of Magnesium Doping on the Light-Induced Hydrophilicity of Zno Thin Films

The Effects of Oxygen Partial Pressure and Substrate Temperature on the Structural and Optical Properties of Zno Films

Microstructure and Optical Properties of ZnO Films Deposited by Radio-frequency Reactive Magnetron Sputtering

Influence of O_2/Ar Flow Ratio on Microstructures and Photoluminescence of ZnO Films

Preparation and properties of nano ZrO2 coating on magnesium alloy

Effect of process parameters on microstructure and Raman characteristics of magnesium doped ZnO thin films

Structural, electronic, and optical study of Zn: MgO compositions by computational and experimental approach

Elucidating the microstructural and optoelectronic properties evolution of sputtered Al-doped MZO thin films

Effect of Substrate Temperature and Deposition Power on the Surface Morphology and Optical Properties of ZnO:Mg Thin Films Deposited by DC Magnetron Sputtering

MICROSTRUCTURE AND PROPERTIES OF ANNEALED ZnO THIN FILMS DEPOSITED BY MAGNETRON SPUTTERING

Nitrogen partial pressure-dependent Mg concentration, structure, and optical properties of Mg x Zn 1− x O film grown by magnetron sputtering

Electron scattering mechanisms in polycrystalline sputtered zinc tin oxynitride thin films

Comparative Study of Aluminum-Doped Zinc Oxide, Gallium-Doped Zinc Oxide and Indium-Doped Tin Oxide Thin Films Deposited by Radio Frequency Magnetron Sputtering

Electrical and structural properties of heterojunction AZO, NZO and NiO thin films

Mg nanostructures with controlled dominant c-plane or m-plane facets by DC magnetron sputter deposition

Structure-dependent optical and electrical transport properties of nanostructured Al-doped ZnO

Structural and Optical Properties of Mg Doped ZnO Thin Films Deposited by DC Magnetron Sputtering

Effects of Oxygen Flow during Fabrication by Magnetron Sputtering on Structure and Performance of Zr-Doped HfO2 Thin Films

Reactive sputtered ZnO thin films: Influence of the O2/Ar flow ratio on the oxygen vacancies and paramagnetic active sites

Microstructure and Young's Modulus of ZrN Thin Film Prepared by Dual Ion Beam Sputtering Deposition