Abstract:The SO2/NOX pollution in the flue gas of non-ferrous smelting is increasingly serious. At the same time, the accumulation of red mud (RM) in the aluminum industry and phosphorus sludge (PS) in the yellow phosphorus industry has caused serious harm to the environment. To remove SO2 and NOX from the non-ferrous smelting flue gas and realize the resource utilization of the above two solid wastes, an ultrasonic field was used in this study to strengthen the PS excited O3 process and RM wet desulfurization and denitrification process. In the process of O3 excitation, the response surface method (RSM) is used to obtain the optimal O3 excitation concentration, and the optimal reaction conditions are designed based on the response surface optimization model: T is 53.226 °C, power density is 0.4 W/cm2, PS concentration is 51.433 g/L, O3 formation concentration up to 250 ppm or more, which provides a theoretical basis for subsequent desulfurization and denitrification steps. It is proved that this study can replace the expensive traditional O3 generator and provide a basis for NOX removal in the following process. In addition, the optimum experimental conditions of ultrasonic enhanced RM desulfurization and denitrification process were also explored. Under ultrasonic frequency of 28 kHz, ultrasonic power density of 0.4 W/cm2, T of 50 °C, RM concentration of 15 g/L, and stirring intensity of 1000 rpm, the desulfurization efficiency of the reaction system can be maintained above 95 % within 250 min, and the denitrification efficiency can be maintained above 90 % within 250 min. The effect of desulfurization and denitrification in this study is much better than that of traditional methods. Finally, the reaction mechanism of ultrasonic enhanced O3 excitation and RM wet desulfurization and nitrogen removal was discussed by combining adsorption thermodynamics, isotherm, and kinetics. The results showed that the OH· free radicals generated by ultrasonic cavitation and the physical effects brought by emulsification had significant promoting effects.

Sludge Reduction in a Full-scale Wastewater Treatment Plant Using Ultra-fine-and Micro-bubble Ozonation

Observations on Ozone Treatment of Excess Sludge

Progress and perspectives of sludge ozonation as a powerful pretreatment method for minimization of excess sludge production.

Enhanced sludge solubilization by microbubble ozonation

Excess sludge conditioning with ultrasound/ozone and its effect on the anaerobic anoxic oxic process in a municipal wastewater treatment plant

Sludge Treatment by O-3/H2o2 and Carbon Source Recovery

Towards zero excess sludge discharge with built-in ozonation for wastewater biological treatment

A method for determining 4-aminopyridine in plasma: pharmacokinetics in anaesthetized guinea pigs after intravenous administration.

Holistic sludge management through ozonation: A critical review

Analysis of the mechanism of sludge ozonation by a combination of biological and chemical approaches.

Reducing excess sludge volume in sequencing batch reactor by integrating ultrasonic waves and ozonation

Analysis of sludge ozonation efficiency and its influencing factors in bubble column

Beneficial role of pre- and post-ozonation in a low rate biofiltration-ultrafiltration process treating reclaimed water

Operation Performance of an A/A/O Process Coupled with Excess Sludge Ozonation and Phosphorus Recovery: A Pilot-Scale Study

Ultrasonic-enhanced Phosphorus Sludge Excited O3 Coupled Red Mud Simultaneous Desulfurization and Denitrification

Evaluation Of Biodegradation Of Soluble And Particulate Matter Produced During Sewage Sludge Ozonation By A Combination Of Chemical And Microbial Approaches

Changes in biomass activity and characteristics of activated sludge exposed to low ozone dose

In-situ sludge reduction based on Mn2+-catalytic ozonation conditioning: Feasibility study and microbial mechanisms

Ozonation As an Advanced Oxidant in Treatment of Bamboo Industry Wastewater.

REDUCTION BY SONICATION OF EXCESS SLUDGE PRODUCTION IN A CONVENTIONAL ACTIVATED SLUDGE SYSTEM: CONTINUOUS FLOW AND LAB‐SCALE REACTOR

Techno-Economic Evaluation of Ozone Application to Reduce Sludge Production in Small Urban WWTPs