Abstract:The treatment of nanoparticle (NP) polluted aqueous suspensions by flotation can be problematic due to the low probability of collision between particles and bubbles. To overcome this limitation, the present work focuses on developing an enhanced flotation technique using the surface-functionalized micro-bubbles - colloidal gas aphrons (CGAs). The CGA generator was adapted to be air flow rate controlled based on the classical Sebba system; thus it could be well adopted in a continuous flotation process. Cetyl trimethylammonium bromide (CTAB) and sodium dodecyl sulfate (SDS) were employed for CGA creation. Positively surface-charged CTAB-CGAs (similar to 44.1 mu m in size) and negatively surface-charged SDS-CGAs (similar to 42.1 mu m in size) were produced at the optimum stirring speed of 8000 rpm. The half-life of CGAs varied from 100 s to 340 s under the tested conditions, which was largely sufficient for transferring CGAs from bubble generator to flotation cell. The air flow led to less stable CTAB-CGAs but apparently enhanced the stability of SDS-CGAs at higher air flow rates. In the presence of air flow, the drainage behavior was not much related to the type of surfactants. The continuous CGA-flotation trials highlighted the effective separation of silica nanoparticles - the removal efficiencies of different types of SiO2 NPs could reach approximately 90%-99%; however, at equivalent surfactant concentrations, no greater than 58% of NPs were removed when surfactants and bubbles were separately added into the flotation cell. The SiO2 NPs with small size were removed more efficiently by the CGA-flotation process. For the flotation with CTAB-CGAs, the neutral and basic initial SNP suspension was recommended, whereas the SDS-CGAs remained high flotation efficiency over all investigated pH. The good performance of CGA-flotation might be interpreted: most of the surfactant molecules well covered/coated on the surfaces of stable CGAs and thus fully contacted with NPs, resulting in the efficient utilization of surfactants. (C) 2017 Elsevier Ltd. All rights reserved.

CONTINUOUS FRACTIONATION OF GLASS MICROSPHERES BY GRAVITATIONAL SEDIMENTATION IN SPLIT-FLOW THIN (SPLITT) CELLS

Surface-modified Microbubbles (colloidal Gas Aphrons) for Nanoparticle Removal in a Continuous Bubble Generation-Flotation Separation System.

Effects of Carrier Liquid and Flow Rate on the Separation in Gravitational Field-Flow Fractionation

Microfluidic Co-Flow of Newtonian and Viscoelastic Fluids for High-Resolution Separation of Microparticles.

Performance of different microfluidic devices in continuous liquid-liquid separation

Near-Infrared Identification of the Dimmest X-ray Sources on the Galactic Plane with the ESO/NTT SOFI Camera

A Numerical Investigation on Segregation in Gas-Fluidized Beds of Short, Flexible Fibers

Continuous Inertial Microparticle And Blood Cell Separation In Straight Channels With Local Microstructures (Vol 16, Pg 532, 2016)

Continuous Elasto-Inertial Separation of Microparticles Using a Co-Flowing Newtonian-viscoelastic Fluid System

Microfluidic Adaptation of Density-Gradient Centrifugation for Isolation of Particles and Cells

Continuous Size-Based Separation of Microparticles in a Microchannel with Symmetric Sharp Corner Structures

Effects of comprehensive function of factors on retention behavior of microparticles in gravitational field-flow fractionation

Continuous Separation of Magnetic Beads Using a Y-shaped Microfluidic System Integrated with Hard-Magnetic Elements

Optimization of Experimental Conditions for the Separation of Polystyrene Particles by Gravitational Field-Flow Fractionation

Gravitational sedimentation induced blood delamination for continuous plasma separation on a microfluidics chip.

Continuous Particle Separation in a Microfluidic Channel Via Standing Surface Acoustic Waves (SSAW)

Research on the ICF Microsphere Separation

Continuous sheathless particle separation in viscoelastic fluids with different rheological properties

Pressure-Driven Phase Separation Based on Modified Porous Mesh for Liquid Management in Microgravity

Study on Liquid–Liquid Droplet Flow Separation in a T-Shaped Microseparator

Particulate And Emulsion Sorting Using Microfluidics