Abstract:Vanadium oxynitride (VN x O y , x+y=1) is a metallic compound between vanadium oxides (VO, V 2 O 3 , V 2 O 5 ) and vanadium nitride (VN) which would have interesting properties and functions that potentially can be supplied for different applications. In this study, vanadium nitride and oxynitride thin films were obtained by reactive magnetron sputtering using vanadium targets, Ar as plasma carrier, and a mix of N 2 and O 2 as reactive gas. The ratio of mass flow between the two gases is maintained around O 2 :N 2 =1:20 during the process. To obtain crystalline phases of oxynitrides a post rapid thermal annealing (RTP) in Ar atmosphere at 600oC and 700oC for 5 minutes was done. The purpose of the study is to define the effect of the magnetron sputtering parameters, such as reactive gas flow rates, and annealing temperature on the composition, microstructure, and optical properties of the obtained vanadium oxynitride thin films. The characterization of obtained films includes the examination of thickness and morphology by the surface profiler and SEM; identifying crystal structures and further microstructural vibration modes of molecular polarizability by X-ray diffraction and Raman spectroscopy, respectively; evaluation of the chemical composition of films by XPS analysis; assessing of optical transmittance, reflectance, and absorbance by the UV-visible- NIR spectrometer. Experimental data reveal that the annealed films can be oxynitrides when the oxygen flow rate is below 0.25 sccm and the ratio of oxygen/nitrogen ≤1/20. The annealed vanadium oxynitride films in terms of their properties are closer to vanadium nitrides than to oxides: more metallic than semi-conductive with dark appurtenance and high optical absorbance across the spectrum between 200 and 900 nm. The optical absorbance reaches almost 90% around 300 nm and then slowly reduces to 70% at 900 nm. Thus, these films could be good optical shields. For practical usage, the deposition of O 2 :N 2 =1/20, O 2 <0.25 sccm, and 600oC annealing are recommended because of the truly low transmittance (<10%) through films.

Anodic Deposition of Vanadium Oxides for Thermal-Induced Growth of Vanadium Oxide Nanowires

Hydrothermal Preparation of Long Nanowires of Vanadium Oxide

Vanadium Pentoxide Nanobelts and Nanorolls: from Controllable Synthesis to Investigation of Their Electrochemical Properties and Photocatalytic Activities

Facile synthesis of vanadium oxide nanowires

One-pot Hydrothermal Synthesis of Vanadium Dioxide Nanoparticles

Hydrothermal Growth And Characterization Of Nanostructured Vanadium-Based Oxides

Wafer-size VO2 film prepared by water-vapor oxidant

Atomic Layer Deposition of Vanadium Oxide Thin Films from Tetrakis(dimethylamino)vanadium Precursor

Ultra-Long, Free-Standing, Single-Crystalline Vanadium Dioxide Micro/Nanowires Grown by Simple Thermal Evaporation

Vanadium Pentoxide Nanowires: Hydrothermal Synthesis, Formation Mechanism, And Phase Control Parameters

Controlled synthesis of VO2(R), VO2(B), and V2O3 vanadium-oxide nanowires

Preparation, Formation Mechanism of V3O7·H2O Single-Crystal Nanobelts

Synthesis of Single-Crystal Vanadium Dioxide Nanosheets by the Hydrothermal Process

Controlled synthesis and characterization of BiVO4 dendrites via a hydrothermal method

Self-Assembly and Horizontal Orientation Growth of VO 2 Nanowires

Low Temperature Synthesis of Vanadium Pentoxide Nanocrystallines by Sol-Gel Method

Annealing-induced oxidation state transition, crystal formation, optical properties, and photocatalytic activity of vanadium oxide nanoparticles

Hydrothermal Synthesis of Vanadium Oxide Microstructures with Mixed Oxidation States

Regulation of morphology and structure of vanadium dioxide via a hydrothermal method for optimizing performances

(Digital Presentation) Fabrication and Characterization for Vanadium Oxynitride Thin Films By Magnetron Sputtering

Facile Growth of Thermochromic VO2Nanostructures with Greatly Varied Phases and Morphologies