Abstract:Rapid and sensitive H2 detection is important because of its low threshold for the formation of explosive mixtures in air (∼4%). Palladium's unique interactions with H2 make it particularly useful in room-temperature H2 sensing, but the formation of water by reaction with O2 at the Pd surface can interfere with sensor response. Here, we report H2 sensors using networks of high aspect ratio and ultrathin reduced graphene oxide (rGO)-coated palladium nanowires (Pd ) with a coating of zeolite imidazole framework (ZIF-8) that serves as a nanofiltration layer. We first produced Pd NWs in high yield by a hydrothermal method, then sonicated them with GO and added a reducing agent to produce Pd Thin Pd NWs promote rapid response and high sensitivity, while rGO prevents the formation of additional conductive channels due to expansion of Pd NWs upon H2 exposure, ensuring monotonic sensor response. The coating of ZIF-8 reduces the transport of molecules like oxygen and nitrogen to the Pd NWs while allowing H2 to reach them and H2O to diffuse away from them. The optimized sensors showed a response (relative change in resistance) to 1% H2 in air of up to 2%, with a response time of 5 s and a lower limit of detection of 20 ppm. Relative to previously reported Pd-based H2 sensors with fast response, the Pd @ZIF-8 nanocomposite-based device provides a low-cost, high-performance sensor solution for fuel-cell vehicles and similar applications that require both rapid and sensitive H2 detection.The Supporting Information is available free of charge at https://pubs.acs.org/doi/10.1021/acsanm.1c01348.FTIR spectra of GO and Pd ; representative EDS spectrum of a bulk Pd nanocomposite material; EDS spectrum of an individual Pd as obtained from STEM imaging; SEM image of a Pd sensor, SEM image of a Pd @ZIF-8 sensor and corresponding elemental mapping of the sensor; XPS spectrum of Pd for (a) Ca 2P, (b) O 1s; Pd NWs (c) C 1s, (d) O 1s; hysteresis curve and the corresponding dynamic H2 sensing curve for Pd NWs; response vs H2 concentration curve of and @ZIF-8 sensors; TEM images, dynamic H2 sensing performance, and EDS spectra of 2 ; comparison of sensor response to repeated exposure to 1% H2; response, response time, and recovery time of Pd NWs, Pd , and Pd @ZIF-8 H2 sensor; the response of @ZIF-8 sensor to 100 ppm of H2, CO, CH4, and CO2; and comparison of dynamic H2 sensor performance of the Pd @ZIF-8 sensor on day 1 and on day 150 (PDF)This article has not yet been cited by other publications.

Fabrication of palladium–zinc oxide–reduced graphene oxide hybrid for hydrogen gas detection at low working temperature

Hydrothermal synthesis of Pd-doped rGO/ZnO-SnO2 nanocomposites for efficient hydrogen detection

Ultralow detection limit and ultrafast response/recovery of the H2 gas sensor based on Pd-doped rGO/ZnO-SnO2 from hydrothermal synthesis

Design of Ultrasensitive Gas Sensor Based on Self-Assembled Pd-SnO2/rGO Porous Ternary Nanocomposites for Ppb-Level Hydrogen

An easy-fabricated hydrogen gas sensor based on palladium-decorated polyurethane nanofibers

Facile Design of Flexible Pd Nanoclusters Sensitized Reduced Graphene Oxide Paper Film Towards Hydrogen Sensing

Pd-Doped Reduced Graphene Oxide Sensing Films for H-2 Detection

Reduced Graphene Oxide-Wrapped Palladium Nanowires Coated with a Layer of Zeolitic Imidazolate Framework-8 for Hydrogen Sensing

One-step preparation of flexible rGO/ZnO gas sensors for ppm-level H2S detection

Fabrication of Graphene/Zinc Oxide Nano-Heterostructure for Hydrogen Sensing

Study of a palladium nanoparticle/ In-Zn-O thin film-based hydrogen gas sensor

Ag Nanoparticle-Modified ZnO–In2O3 Nanocomposites for Low-Temperature Rapid Detection Hydrogen Gas Sensors

Interconnected Pd Nanoparticles Supported on Zeolite-AFI for Hydrogen Detection under Ultralow Temperature

Performance Improvement of n-ZnO/p-rGO Heterojunction Based Room Temperature Hydrogen Gas Sensor

Preparation and Hydrogen-Sensitive Property of WO3/Graphene/Pd Ternary Composite

Doping Composite of Polyaniline and Reduced Graphene Oxide with Palladium Nanoparticles for Room-Temperature Hydrogen-Gas Sensing

Two-Dimensional Dy2O3-Pd-PDA/rGO Heterojunction Nanocomposite: Synergistic Effects of Hybridisation, UV Illumination and Relative Humidity on Hydrogen Gas Sensing

One Step from Nanofiber to Functional Hybrid Structure: Pd Doped ZnO/SnO2 Heterojunction Nanofibers with Hexagonal ZnO Columns for Enhanced Low-Temperature Hydrogen Gas Sensing

Low detection based on Pd Pt /In2O3 nanospheres for rapid hydrogen detection

Highly Sensitive Room Temperature Hydrogen Sensor Based on Cactus-like ZnO@3D rGO Aerogel

Ultrasensitive and Wide‐Range Flexible Hydrogen Sensor Based on Pd Nanoparticles Decorated Ultrathin SnO2 Film