Abstract:The purpose of this work is to measure bubble size distribution of bubbly flows in the column by using image analysis technology.Firstly,images of bubbles for a range of superficial gas velocities are obtained by using high speed camera with lighting emitting diode(LED)as a light source.Air and water are used as gas-liquid bubbly flows.Then,the images are preprocessed and converted into binary images by employing Matlab.Thus,perimeters and areas as factors of roundness are extracted to classify bubbles into overlapping and solitary bubbles.Solitary bubbles are separated to prevent the software segmenting them mistakenly.The size distribution of solitary bubbles is achieved by the use of formula.Then the overlapping bubbles are segmented into solitary bubbles by the use of an improved watershed algorithm.Finally,the size distribution of all bubbles at different gas velocities is analyzed and compared with the distribution without watershed.It shows that the size distribution with watershed is more accurate than the size distribution without watershed.The gas hold-up has also been calculated by the use of size distribution.In order to check the accuracy of the result,the calculated gas hold-up and actual gas hold-up have been compared and the measurement error between those two is expressed in the form of figure.The error grows with the increase of superficial gas velocity,less than 10% at 1.2~1.8 cm·s-1 .But the size dis-tribution obtained by the image analysis technology cannot describe the actual gas hold-up when the superficial gas velocity is more than 2.0 cm·s-1 .In spite of this,the size distribution detected can help us to learn more rules of bubble motion.For example,the growth trend of the bubble’s interfacial area slows down with the increase of superficial gas velocity.And the resulting bubble size distribution with the superficial velocity between 1.2 cm·s-1 and 2.0 cm·s-1 is shown in the form of probability density function(PDF).

Bubble size distribution in cyclonic zone of a novel flotation column

Study on bubble size distribution and local gas holdup in bubble column

Experimental and Numerical Investigations of Scale-Up Effects on the Hydrodynamics of Slurry Bubble Columns

Experimental Investigation of Flow Development in Large-Scale Bubble Columns in the Churn-Turbulent Regime

Cfd Simulation of Bubble Dynamics in Bubble Columns with Internals

Bubble Size “bimodal” Distribution Enhances Mixing and Mass Transfer in Slurry Bubbling Column Reactor

Evolution and Interaction Characteristics of Liquid Flow and Bubbles in a Jet Bubbling Column

Experimental Measurement and Theoretical Analysis on Bubble Dynamic Behaviors in a Gas-Liquid Bubble Column

A study of bubble size/shape evolution in microbubble countercurrent contacting flotation column

Bubble size and its distribution for Venturi bubble generator

CFD Simulation of Gas-Liquid Flow in Bubble Column with Two-bubble Phase Population Balance Model

Study of a Novel Fluidized Bed Flotation Column with Enhanced Bubble Dispersion

Rising and descending bubble size distributions in gas–liquid and gas–liquid–solid slurry bubble column reactor

Bubble velocity distribution in liquid-gas two-phase flow of flotation column using PDA velocimeter

CFD-PBM simulation of power law fluid in a bubble column reactor

Detection and analysis of bubble size distribution in liquid phase

Bubble Statistics in Shallow Angle Plunging Liquid Jets

Microbubble Generation with Shear Flow on Large-Area Membrane for Fine Particle Flotation

Direct numerical simulation of deformable rising bubbles at low Reynolds numbers

Numerical Simulation of Local Bubble Size Distribution in Bubble Columns Operated at Heterogeneous Regime

Bubble Size Distribution at Early Stage of Hydrodynamic Cloud Cavitation