Abstract:The purpose of this work is to measure bubble size distribution of bubbly flows in the column by using image analysis technology.Firstly,images of bubbles for a range of superficial gas velocities are obtained by using high speed camera with lighting emitting diode(LED)as a light source.Air and water are used as gas-liquid bubbly flows.Then,the images are preprocessed and converted into binary images by employing Matlab.Thus,perimeters and areas as factors of roundness are extracted to classify bubbles into overlapping and solitary bubbles.Solitary bubbles are separated to prevent the software segmenting them mistakenly.The size distribution of solitary bubbles is achieved by the use of formula.Then the overlapping bubbles are segmented into solitary bubbles by the use of an improved watershed algorithm.Finally,the size distribution of all bubbles at different gas velocities is analyzed and compared with the distribution without watershed.It shows that the size distribution with watershed is more accurate than the size distribution without watershed.The gas hold-up has also been calculated by the use of size distribution.In order to check the accuracy of the result,the calculated gas hold-up and actual gas hold-up have been compared and the measurement error between those two is expressed in the form of figure.The error grows with the increase of superficial gas velocity,less than 10% at 1.2~1.8 cm·s-1 .But the size dis-tribution obtained by the image analysis technology cannot describe the actual gas hold-up when the superficial gas velocity is more than 2.0 cm·s-1 .In spite of this,the size distribution detected can help us to learn more rules of bubble motion.For example,the growth trend of the bubble’s interfacial area slows down with the increase of superficial gas velocity.And the resulting bubble size distribution with the superficial velocity between 1.2 cm·s-1 and 2.0 cm·s-1 is shown in the form of probability density function(PDF).

Wavelet Analysis of Turbulent Structure at Superficial Velocity in Bubble Column

Study on bubble size distribution and local gas holdup in bubble column

Experimental Investigation of Flow Development in Large-Scale Bubble Columns in the Churn-Turbulent Regime

Experimental and Numerical Investigations of Scale-Up Effects on the Hydrodynamics of Slurry Bubble Columns

Studies on Hydrodynamics of Turbulent Slurry Bubble Column ( Ⅴ )modeling of Bubble Column with Multi-Layer Screens

The Measurement of Local Gas Holdup under High Superficial Velocity in Bubble Column

Wavelet Transform of Velocity-Time Data for the Analysis of Turbulent Structures in a Trayed Bubble Column

Studies on hydrodynamics of slurry turbulent bubble column(Ⅰ) Gas holdup and its radial distribution

2-D Hydrodynamic Model of Bubble Column Based on Lateral-Force Balance

CFD simulation of bubble column with vertical bundle internals

Experimental Measurement and Theoretical Analysis on Bubble Dynamic Behaviors in a Gas-Liquid Bubble Column

CFD Simulation of Gas-Liquid Flow in Bubble Column

Evolution and Interaction Characteristics of Liquid Flow and Bubbles in a Jet Bubbling Column

Influence of Short-Draft Tube on Fluid Dynamics in Bubble Column with CFD

Bubble size and its distribution for Venturi bubble generator

Modelling of Mass Transfer for Gas-Liquid Two-Phase Flow in Bubble Column Reactor with a Bubble Breakage Model Considering Bubble-Induced Turbulence

Bubble Statistics in Shallow Angle Plunging Liquid Jets

Liquid Velocity Profile of Turbulent Bubbly Flow in a Large Square Duct

Gas-Liquid Bubbly Turbulent Upward Flow in Square Duct

Detection and analysis of bubble size distribution in liquid phase

Numerical Analysis of Single Pulsating Bubble Interaction with a Free Surface in a Viscous Compressible Liquid