Abstract:The viability of hydrothermal pretreatment (HTP) to improve the efficiency of biogas production from municipal solid wastes (MSWs) is uncertain because there is always a trade-off between organic matters hydrolysis and recalcitrant melanoidins formation when applying HTP on different solid wastes. In this study, MSWs including waste activated sludge, fruit and vegetable residues, and kitchen wastes, with and without HTP were digested in the one phase and two-phase anaerobic digesters, respectively. Although the specific biogas production of MSWs in two-phase anaerobic digestion was significantly enhanced by HTP, no benefit could be found in one-phase anaerobic digestion because of the melanoidins formation. The specific biogas production of hydrothermally pretreated MSWs was much higher in two-phase anaerobic digestion (0.71 L biogas/g VSadded) than that of MSWs in one-phase anaerobic digestion with or without HTP (0.53 L and 0.55 L biogasig VSadded) when the butyric acid type fermentation dominated in the acidogenic phase. These findings indicated that the recalcitrant melanoidins formed in the HTP process were probably removed in the acidogenic digester. Differing from previous study, mixed-acid type fermentation, rather than ethanol type fermentation, was observed in the acidogenic digester fed with hydrothermally pretreated feedstock when pH was adjusted in the range of 4.0-4.5 with high oxidation reduction potential values of 49-97 my. The succeeding specific biogas production of mixed-acid type feedstock was only 0.59 L biogas/g VSadded, which was lower than that of the butyric acid type feedstock. Microbial community structure was independent of the pH valties and was substrate-specific in the acidogenic digesters. In the acidogenic digester with the HTP substrate, the phylum Firmicutes and Bacteroidetes increased, thereby possibly resulting from the increased content of soluble sugar and proteins in the HTP feedstock. Energy balance estimation of the four defined scenarios indicated that the combined HTP and two-phase AD in the MSWs treatment can achieve higher net energy output by 50.5-97.4% compared to the other three scenarios. This enables the combined process of HTP and two-phase AD to be a promising alternative way in the treatment of feedstock rich in protein and sugar. (C) 2016 Elsevier Ltd. All rights reserved.

Optimisation of anaerobic co-digestion in two-stage systems for hydrogen, methane and biofertiliser production

Agronomic and phytotoxicity test with biosolids from anaerobic CO-DIGESTION with temperature and micro-organism phase separation, based on sewage sludge, vinasse and poultry manure

Assessment of the Feasibility of Converting the Liquid Fraction Separated from Fruit and Vegetable Waste in a UASB Digester

Optimising sewage sludge anaerobic digestion for resource recovery in wastewater treatment plants

Optimization of Temperature-separated Two-stage Anaerobic Fermentation Process Treating waste activated sludge and food waste

Increasing 2 -Bio- (H2 and CH4) production from food waste by combining two-stage anaerobic digestion and electrodialysis for continuous volatile fatty acids removal

Two-phase (acidogenic-methanogenic) anaerobic fixed bed biofilm reactor enhances the biological domestic sewage treatment: Perspectives for recovering bioenergy and value-added by-products

Biowaste management by hydrothermal carbonization and anaerobic co-digestion: Synergistic effects and comparative metagenomic analysis

Biomethane Production from the Two-Stage Anaerobic Co-Digestion of Cow Manure: Residual Edible Oil with Two Qualities of Waste-Activated Sludge

Hydrogen and Methane Production in a Two-Stage Thermophilic Anaerobic Digestion System by Co-Digestion of Kitchen Waste and Municipal Sewage Sludge with a High Solid Content

Fermentative hydrogen and methane co-production from anaerobic co-digestion of organic wastes at high loading rate coupling continuously and sequencing batch digesters

Thermally enhanced solid–liquid separation process in food waste biorefinery: modelling the anaerobic digestion of solid residues

System Integration of Hydrothermal Liquefaction and Anaerobic Digestion for Wet Biomass Valorization: Biodegradability and Microbial Syntrophy.

Synergetic Hydrogen and Methane Productions from Anaerobic Digestion of Selected Rural-Farming Plant and Animal-Based Biomass Wastes

Two-phase Anaerobic Co-Digestion of Food Waste and Sewage Sludge.

Stimulating Methane Production from Poultry Manure Digest with Sewage Sludge and Organic Waste by Thermal Pretreatment and Adding Iron or Sodium Hydroxide

Two-stage Anaerobic Digestion of Food Waste and Horticultural Waste in High-Solid System

Optimization of Operating Parameters for Two-Phase Anaerobic Digestion Treating Slaughterhouse Wastewater for Biogas Production: Focus on Hydrolytic–Acidogenic Phase

Two-Phase Anaerobic Digestion of Municipal Solid Wastes Enhanced by Hydrothermal Pretreatment: Viability, Performance and Microbial Community Evaluation

Optimization Of Cattle Manure And Food Waste Co-Digestion For Biohydrogen Production In A Mesophilic Semi-Continuous Process

Composting of the Solid Phase of Digestate from Biogas Production: Optimization of the Moisture, C/N Ratio, and pH Conditions