Abstract:Organic matter and nutrients present in urban and industrial wastewater should be removed or valorised to reduce its impact on the environment. Conventional wastewater treatments are focused on the removal of these pollution sources at the minimum cost. The idea of resource recovery from wastewater is changing the concept of the conventional wastewater treatment plants that tend to incorporate little by little processes as anaerobic digestion, MBR, biofilm, granulation, etc. However, their application to obtain reusable by-products from wastes should be cost effective. Winery wastewater is an effluent with a highly biodegradable organic load, worth considering for biogas production, and low nutrient content. A sidestream anaerobic membrane bioreactor (AnMBR) was started up and operated under organic load oscillations. The stable operation was assured by keeping a ratio between intermediate alkalinity and total alkalinity (IA/TA) below 0.3 achieving a 96.7±2.7% COD removal efficiency. The biogas production varied according with the OLR that was on average 0.50±0.17 m(3)(biogas)/m(-3)(digester)/d(-1) with an 87.1±3.0% of methane. The external membrane module reached a flux of 20.2 ± 8.5 LMH at a crossflow velocity of 0.64 m s-1. The crossflow velocity helped to remove the cake layer attached on the membrane that was the main contribution (>80%) to flux decline. The energy demand of the AnMBR was calculated considering the net energy production of a combined heat and power (CHP) unit. It was concluded that only when influent COD was over 3.25 gCOD 1:1- the energy balance was positive. Considering the upscaling of the AnMBR of the present study, the submerged membrane configuration would be a more feasible option due to its lower operational costs, especially in winter season. Simulating the conditions of winter season, winery wastewater was treated in the AnMBR at low temperatures of 25°C and 15°C. Since the organic load of winery wastewater in winter is much lower than in summer (vintage season), the average OLR applied was 0.32 and 0.29 kgCOD m(-3)(digester)/d(-1) the average COD removal reached was 80% and 71% at 25°C and 15°C., respectively. Moreover, higher degree of fouling was observed despite the amount of suspended solids was lower, so frequent cleanings were necessary. The effluent of anaerobic digestion often requires a post-treatment to remove nutrients, especially nitrogen. Compared with conventional biological nitrogen removal, nitritation/denitritation (N/DN) via nitrite represent a 25% less aeration and 40% less external carbon source. In order to reach higher flexibility and reducing space requirements, N/DN can be carried out in a sequencing batch reactor (SBR). Under feast and famine conditions applied in the SBR, storage compounds can be served as internal carbon sources for post-anoxic denitrification. A novel scheme was developed for the treatment of municipal wastewater; consisting in an UASB reactor followed by a short cut sequencing batch reactor (scSBR) in the main water line. Nitritation/denitritation was integrated with the selection of polyhydroxyalkanoate (PHA) storing biomass. Biowaste fermented liquid was applied as carbon source in the feast regime. The average nitrogen removal was 83%. After achieving an acceptable ammonia removal of 93%, there was enough available PHA for the subsequent denitritation, reaching a maximum nitrite removal of 98%. The maximum PHA content was 10.6% (gPHA gTSS-1) after 10 h of accumulation when biowaste fermented liquid (C/N/P= 100/4.5/0.42) was applied. Nitrogen removal limits could be successfully met while PHA-storing biomass was selected. Although higher PHA yields can be achieved under complete aerobic conditions, this novel scheme presents an added value due to the integration of the PHA production in the nitritation/denitritation process.

Thermally enhanced solid–liquid separation process in food waste biorefinery: modelling the anaerobic digestion of solid residues

Assessment of the Feasibility of Converting the Liquid Fraction Separated from Fruit and Vegetable Waste in a UASB Digester

Biowaste management by hydrothermal carbonization and anaerobic co-digestion: Synergistic effects and comparative metagenomic analysis

Converting Organic Municipal Solid Waste into Volatile Fatty Acids and Biogas: Experimental Pilot and Batch Studies with Statistical Analysis

Acidogenic fermentation of biowaste coupled with nitrogen recovery using selective membranes to produce a VFA-rich liquid with a high C/N ratio

Optimisation of anaerobic co-digestion in two-stage systems for hydrogen, methane and biofertiliser production

Characterization and treatment of the liquid effluents from the anaerobic digestion of biogenic solid waste

A Half-Submerged Integrated Two-Phase Anaerobic Reactor for Agricultural Solid Waste Codigestion

Biohythane, Biogas, and Biohydrogen Production from Food Waste: Recent Advancements, Technical Bottlenecks, and Prospects

Pyrolysis of Difficult Biodegradable Fractions and the Real Syngas Bio-Methanation Performance

Dry Anaerobic Digestion of the Organic Fraction of Municipal Solid Waste: Biogas Production Optimization by Reducing Ammonia Inhibition

Bio-Delignification of Green Waste (GW) in Co-Digestion with the Organic Fraction of Municipal Solid Waste (OFMSW) to Enhance Biogas Production

Plastic-containing food waste conversion to biomethane, syngas, and biochar via anaerobic digestion and gasification: Focusing on reactor performance, microbial community analysis, and energy balance assessment

A contribution to resource recovery from wastewater. Anaerobic processes for organic matter and nitrogen treatment

Performance Assessment and Metagenomic Analysis of Full-Scale Innovative Two-Stage Anaerobic Digestion Biogas Plant for Food Wastes Treatment

Multivariate insights into enhanced biogas production in thermophilic dry anaerobic co-digestion of food waste with kitchen waste or garden waste: Process properties, microbial communities and metagenomic analyses

Metagenomic characterization of the enhanced performance of multicomponent synergistic thermophilic anaerobic co-digestion of food waste utilizing kitchen waste or garden waste as co-substrate

Advancing the bioconversion process of food waste into methane: A systematic review

Innovative system to maximize methane production from fruit and vegetable waste

Technical feasibility and modeling of enzymatic pre-treatments of organic fraction of municipal solid waste to improve anaerobic digestion

Kinetic modelling and synergistic impact evaluation for the anaerobic co-digestion of distillers' grains and food waste by ethanol pre-fermentation