Abstract:Organic matter and nutrients present in urban and industrial wastewater should be removed or valorised to reduce its impact on the environment. Conventional wastewater treatments are focused on the removal of these pollution sources at the minimum cost. The idea of resource recovery from wastewater is changing the concept of the conventional wastewater treatment plants that tend to incorporate little by little processes as anaerobic digestion, MBR, biofilm, granulation, etc. However, their application to obtain reusable by-products from wastes should be cost effective. Winery wastewater is an effluent with a highly biodegradable organic load, worth considering for biogas production, and low nutrient content. A sidestream anaerobic membrane bioreactor (AnMBR) was started up and operated under organic load oscillations. The stable operation was assured by keeping a ratio between intermediate alkalinity and total alkalinity (IA/TA) below 0.3 achieving a 96.7±2.7% COD removal efficiency. The biogas production varied according with the OLR that was on average 0.50±0.17 m(3)(biogas)/m(-3)(digester)/d(-1) with an 87.1±3.0% of methane. The external membrane module reached a flux of 20.2 ± 8.5 LMH at a crossflow velocity of 0.64 m s-1. The crossflow velocity helped to remove the cake layer attached on the membrane that was the main contribution (>80%) to flux decline. The energy demand of the AnMBR was calculated considering the net energy production of a combined heat and power (CHP) unit. It was concluded that only when influent COD was over 3.25 gCOD 1:1- the energy balance was positive. Considering the upscaling of the AnMBR of the present study, the submerged membrane configuration would be a more feasible option due to its lower operational costs, especially in winter season. Simulating the conditions of winter season, winery wastewater was treated in the AnMBR at low temperatures of 25°C and 15°C. Since the organic load of winery wastewater in winter is much lower than in summer (vintage season), the average OLR applied was 0.32 and 0.29 kgCOD m(-3)(digester)/d(-1) the average COD removal reached was 80% and 71% at 25°C and 15°C., respectively. Moreover, higher degree of fouling was observed despite the amount of suspended solids was lower, so frequent cleanings were necessary. The effluent of anaerobic digestion often requires a post-treatment to remove nutrients, especially nitrogen. Compared with conventional biological nitrogen removal, nitritation/denitritation (N/DN) via nitrite represent a 25% less aeration and 40% less external carbon source. In order to reach higher flexibility and reducing space requirements, N/DN can be carried out in a sequencing batch reactor (SBR). Under feast and famine conditions applied in the SBR, storage compounds can be served as internal carbon sources for post-anoxic denitrification. A novel scheme was developed for the treatment of municipal wastewater; consisting in an UASB reactor followed by a short cut sequencing batch reactor (scSBR) in the main water line. Nitritation/denitritation was integrated with the selection of polyhydroxyalkanoate (PHA) storing biomass. Biowaste fermented liquid was applied as carbon source in the feast regime. The average nitrogen removal was 83%. After achieving an acceptable ammonia removal of 93%, there was enough available PHA for the subsequent denitritation, reaching a maximum nitrite removal of 98%. The maximum PHA content was 10.6% (gPHA gTSS-1) after 10 h of accumulation when biowaste fermented liquid (C/N/P= 100/4.5/0.42) was applied. Nitrogen removal limits could be successfully met while PHA-storing biomass was selected. Although higher PHA yields can be achieved under complete aerobic conditions, this novel scheme presents an added value due to the integration of the PHA production in the nitritation/denitritation process.

A contribution to resource recovery from wastewater. Anaerobic processes for organic matter and nitrogen treatment

Integrating Anaerobic Acidification with Two-Stage Forward Osmosis Concentration for Simultaneously Recovering Organic Matter, Nitrogen and Phosphorus from Municipal Wastewater.

Swine Manure Treatment by Anaerobic Membrane Bioreactor with Carbon, Nitrogen and Phosphorus Recovery

Assessment of the Feasibility of Converting the Liquid Fraction Separated from Fruit and Vegetable Waste in a UASB Digester

Characterization and treatment of the liquid effluents from the anaerobic digestion of biogenic solid waste

Acidogenic fermentation of biowaste coupled with nitrogen recovery using selective membranes to produce a VFA-rich liquid with a high C/N ratio

An urban biorefinery for food waste and biological sludge conversion into polyhydroxyalkanoates and biogas

Enhanced ammonium removal from liquid anaerobic digestion residuals in an advanced sequencing batch reactor system

Coupling AnMBR, Primary Settling and Anaerobic Digestion to Improve Carbon Fate When Treating Sulfate-Rich Wastewater

Enhanced Nitrogen and Phosphorus Removal from Municipal Wastewater in an Anaerobic-Aerobic-anoxic Sequencing Batch Reactor with Sludge Fermentation Products As Carbon Source.

Physiological and Microbial Community Analysis During Municipal Organic Waste Leachate Treatment by a Sequential Nitrification-Denitrification Process

Low carbon-to-nitrogen ratio digestate from high-rate anaerobic baffled reactor facilitates heterotrophic/autotrophic nitrifiers involved in nitrogen removal

Assessment of the performance of a symbiotic microalgal-bacterial granular sludge reactor for the removal of nitrogen and organic carbon from dairy wastewater

Dry Anaerobic Digestion of the Organic Fraction of Municipal Solid Waste: Biogas Production Optimization by Reducing Ammonia Inhibition

Carbon and nitrogen removal from a wastewater of an industrial dairy laboratory with a coupled anaerobic filter-sequencing batch reactor system.

Resources recovery from domestic wastewater by a combined process: anaerobic digestion and membrane photobioreactor

A Membrane Bioreactor for an Innovative Biological Nitrogen Removal Process.

Nitritating-anammox biomass tolerant to high dissolved oxygen concentration and C/N ratio in treatment of yeast factory wastewater

Evaluating the potential of a new reactor configuration to enhance simultaneous organic matter and nitrogen removal in dairy wastewater treatment

Multi-parameter control-based operation strategy for mainstream deammonification in an integrated anaerobic biofilm reactor-step feed MBR

A New Efficient Paradigm of Energy and Resource Recovery from Sewage: AnMBR Treating Chemically Pre-Precipitated Concentrate in Sidestream