Abstract:Organic matter and nutrients present in urban and industrial wastewater should be removed or valorised to reduce its impact on the environment. Conventional wastewater treatments are focused on the removal of these pollution sources at the minimum cost. The idea of resource recovery from wastewater is changing the concept of the conventional wastewater treatment plants that tend to incorporate little by little processes as anaerobic digestion, MBR, biofilm, granulation, etc. However, their application to obtain reusable by-products from wastes should be cost effective. Winery wastewater is an effluent with a highly biodegradable organic load, worth considering for biogas production, and low nutrient content. A sidestream anaerobic membrane bioreactor (AnMBR) was started up and operated under organic load oscillations. The stable operation was assured by keeping a ratio between intermediate alkalinity and total alkalinity (IA/TA) below 0.3 achieving a 96.7±2.7% COD removal efficiency. The biogas production varied according with the OLR that was on average 0.50±0.17 m(3)(biogas)/m(-3)(digester)/d(-1) with an 87.1±3.0% of methane. The external membrane module reached a flux of 20.2 ± 8.5 LMH at a crossflow velocity of 0.64 m s-1. The crossflow velocity helped to remove the cake layer attached on the membrane that was the main contribution (>80%) to flux decline. The energy demand of the AnMBR was calculated considering the net energy production of a combined heat and power (CHP) unit. It was concluded that only when influent COD was over 3.25 gCOD 1:1- the energy balance was positive. Considering the upscaling of the AnMBR of the present study, the submerged membrane configuration would be a more feasible option due to its lower operational costs, especially in winter season. Simulating the conditions of winter season, winery wastewater was treated in the AnMBR at low temperatures of 25°C and 15°C. Since the organic load of winery wastewater in winter is much lower than in summer (vintage season), the average OLR applied was 0.32 and 0.29 kgCOD m(-3)(digester)/d(-1) the average COD removal reached was 80% and 71% at 25°C and 15°C., respectively. Moreover, higher degree of fouling was observed despite the amount of suspended solids was lower, so frequent cleanings were necessary. The effluent of anaerobic digestion often requires a post-treatment to remove nutrients, especially nitrogen. Compared with conventional biological nitrogen removal, nitritation/denitritation (N/DN) via nitrite represent a 25% less aeration and 40% less external carbon source. In order to reach higher flexibility and reducing space requirements, N/DN can be carried out in a sequencing batch reactor (SBR). Under feast and famine conditions applied in the SBR, storage compounds can be served as internal carbon sources for post-anoxic denitrification. A novel scheme was developed for the treatment of municipal wastewater; consisting in an UASB reactor followed by a short cut sequencing batch reactor (scSBR) in the main water line. Nitritation/denitritation was integrated with the selection of polyhydroxyalkanoate (PHA) storing biomass. Biowaste fermented liquid was applied as carbon source in the feast regime. The average nitrogen removal was 83%. After achieving an acceptable ammonia removal of 93%, there was enough available PHA for the subsequent denitritation, reaching a maximum nitrite removal of 98%. The maximum PHA content was 10.6% (gPHA gTSS-1) after 10 h of accumulation when biowaste fermented liquid (C/N/P= 100/4.5/0.42) was applied. Nitrogen removal limits could be successfully met while PHA-storing biomass was selected. Although higher PHA yields can be achieved under complete aerobic conditions, this novel scheme presents an added value due to the integration of the PHA production in the nitritation/denitritation process.

Assessment of the performance of a symbiotic microalgal-bacterial granular sludge reactor for the removal of nitrogen and organic carbon from dairy wastewater

Synergistic Effect of Chitosan-Based Sludge Aggregates CS@NGS Inoculum Accelerated the Start-Up of Biofilm Reactor Treating Aquaculture Effluent: Insights into Performance, Microbial Characteristics, and Functional Genes.

A Case for Aerobic Sludge Granulation: from Pilot to Full Scale

Treatment of dairy effluents in an aerobic granular sludge sequencing batch reactor

Carbon and nitrogen removal from a wastewater of an industrial dairy laboratory with a coupled anaerobic filter-sequencing batch reactor system.

Optimizing sequencing batch reactor (SBR) reactor operation for treatment of dairy wastewater with aerobic granular sludge

Evaluating the potential of a new reactor configuration to enhance simultaneous organic matter and nitrogen removal in dairy wastewater treatment

Improvement in Post-Treatment of Digested Swine Wastewater

The microbiome of two strategies for ammonia removal with the sequencing batch moving bed biofilm reactor treating cheese production wastewater

A contribution to resource recovery from wastewater. Anaerobic processes for organic matter and nitrogen treatment

Elucidating performance failures in use of granular sludge for nutrient removal from domestic wastewater in a warm coastal climate region

Effective removal of organic substances and nutrients using microgranular sludge in a sequential batch reactor

Evaluation of an aerobic granular sludge reactor with biological filtration (AGS-BF reactor) in municipal wastewater treatment: A new configuration

Nitrogen and phosphorus removal from an abattoir wastewater in a SBR with aerobic granular sludge

Impact of Influent Composition and Operating Conditions on Carbon and Nitrogen Removal from Urban Wastewater in a Continuous-Upflow (Micro)Aerobic Granular Sludge Blanket Reactor

Symbiotic treatment of ammonia-nitrogen wastewater by algae and activated sludge: effects of algae and sludge inoculation rates

Enhanced ammonium removal from liquid anaerobic digestion residuals in an advanced sequencing batch reactor system

To Optimize Sequencing Batch Reactor (SBR) and Monitor Aerobic Granular Sludge (AGS) Development for Domestic Wastewater Treatment

Treatment of real domestic sewage in a pilot‐scale aerobic granular sludge reactor: Assessing start‐up and operational control

Post-treatment of swine wastewater using aerobic granular sludge: Granulation, microbiota development, and performance

Coupling AnMBR, Primary Settling and Anaerobic Digestion to Improve Carbon Fate When Treating Sulfate-Rich Wastewater