Abstract:The use of renewable energies and alternative fuels to replace fossil fuels is a goal for reducing greenhouse gas emissions. Biogas is a promising option to substitute natural gas, but adequate purification of the produced biogas is necessary (the CO2 content of raw biogas must be reduced). Membrane technologies have proven its technical viability to purify biogas until the defined requirements. Moreover, membranes based on biopolymers could reduce the environmental footprint of these purification processes. Nevertheless, due to the trade-off between purity and recovery, single-stage processes are not able to attain desired targets, so multiple stages are required to reach the desired high purities and recoveries. The aim of this study is to advance the use of biopolymer-based membranes for the separation of CO2/CH4 and evaluate the economic competitiveness of the designed multistage purification process. For this purpose, a chitosan composite membrane with organic (ionic liquid) and inorganic (titanosilicate) fillers in the selective layer was used to study the multistage configuration, considering CO2 and CH4 as both target products. The process configuration is based on three membrane units operating in series to enrich CO2 in the product stream from the permeate line, while the retentates are collected from each stage and mixed to obtain a CH4-rich stream in the retentate. The target objectives were purities and recoveries of ≥95% of CO2 in the permeate outlet and ≥97% of CH4 in the retentate outlet stream of the multistage process. The economic evaluation of the proposed three-stage separation process was performed for different process scales, from small installations to large plants (100–1000 N m3 h–1 feed flow rate basis), operated with two different pressure ratios (8 and 16). Total specific costs and contributions of the different cost terms to fixed and operating costs were estimated. Operating costs were the largest contributor to total costs in all of the scenarios studied. To highlight the total specific costs for the installations of 1000 N m3 h–1 capacity, the obtained total costs were 0.33 and 0.20 US $ N m3– for the 8 and 16 pressure ratio values, respectively. This latter cost was competitive when compared to the cost published in the literature. Moreover, a sensitivity analysis was performed to evaluate the effects of increased specific costs of materials (membrane cost) and energy (electricity cost) on the total specific costs of the three-stage separation process.

Biogas desulfurization and biogas upgrading using a hybrid membrane system--modeling study.

The calculation and experimental study of reactive sorption enhanced steam reforming of modeled biogas for hydrogen production

Membrane biogas upgrading processes for the production of natural gas substitute

RESEARCH OF METHANE PRODUCTION PROCESS FROM BIOGAS AND PYROLYSIS GAS

Process optimization of CO2membrane and cryogenic hybrid separation

Performance Analysis of Membrane Separation for Upgrading Biogas to Biomethane at Small Scale Production Sites

Biogas Upgrading Using a Single-Membrane System: A Review

A review of membrane material for biogas and natural gas upgrading

Recovery of Methanol during Natural Gas Dehydration Using Polymeric Membranes: Modeling of the Process

Status and future trends of hollow fiber biogas separation membrane fabrication and modification techniques

Modeling and simulation of high pressure water scrubbing technology applied for biogas upgrading

Comprehensive experimental and theoretical insights into the performance of polysulfone hollow-fiber membrane modules in biogas purification process

Modelling and optimization of hybrid PSA/membrane separation processes

Techno-Economic Optimization of Multistage Membrane Processes with Innovative Hollow Fiber Modules for the Production of High-Purity CO2 and CH4 from Different Sources

Exergy-based sustainability analysis of biogas upgrading using a hybrid solvent (imidazolium-based ionic liquid and aqueous monodiethanolamine)

Membrane bioreactors for syngas permeation and fermentation

Analysis of the Techno-Economic Competitiveness of a Three-Stage Membrane Separation Process for Biogas Upgrading Using a Biopolymer-Based Mixed-Matrix Membrane

Process Simulation and Cost Evaluation of Carbon Membranes for CO2 Removal from High-Pressure Natural Gas

Biological upgrading of biogas assisted with membrane supplied hydrogen gas in a three-phase upflow reactor

Development of cost-effective cellulose-based bilayer hybrid composite membranes for CO2 separation in biogas purification

Anaerobic digestion biogas upgrading using a two-stage membrane system under pilot-scale conditions.