Abstract:<p>The adoptions of mini-channel and nanofluid are potential technologies to improve the heat transfer capability. The present study experimentally investigated the flow and thermal performance of EG/water based ZnO nanofluid inside a mini-channel with serrated fins with an equivalent diameter of 1.59 mm. EG/water mixture with a mass fraction of 40%/60% served as the base fluid. Nanofluids with a volumetric concentration of 0.75 vol% and 1.5 vol% were prepared. The thermophysical properties of viscosity, density and thermal conductivity were measured. It reveals that although the adding of nanoparticles is able to improve the thermal conductivity by 4.2% on average, the viscosity also enlarges remarkably by up to 18.9%. The measured density and thermal conductivity can be predicted accurately by existing formulations. As all correlations underestimate the viscosity, a new one is proposed for the fabricated nanofluid with a small Mean Absolute Relative Deviation (MARD) of 0.1%. The Nusselt number can be averagely improved by 10.6% and 13.2% for the 0.75 vol% and 1.5 vol% nanofluid with a corresponding sacrifice of friction factor augmentation of 31.2% and 47.3% respectively due to the significant augmentation of viscosity, which results in a relatively small heat transfer coefficient enhancement ratio of 0.92–1.09 under the same pumping power. In addition, the heat transfer enhancement shows a nonlinear increment with the concentration and a higher relative enhancement is found at a lower concentration. This indirectly indicates that the heat transfer does not always increase with the concentration. Even though some published correlations present acceptable predictions for the tested flow and thermal performance of EG/water based ZnO nanofluid, the newly developed Backpropagation Artificial Neural Networks (BP-ANNs) show even better prediction accuracies for Nusselt number and friction factor with the MARDs of 0.39% and 0.35% respectively. Our study is expected to give valuable data sources and inspiration for future investigation on hydrodynamic and thermal behavior of nanofluids.</p>

Experimental study on the thermal and flow characteristics of ZnO/water nanofluid in mini-channels integrated with GA-optimized ANN prediction and CFD simulation

Experimental and artificial neural network based study on the heat transfer and flow performance of ZnO-EG/water nanofluid in a mini-channel with serrated fins

Experimental study and CFD modelling on the thermal and flow behavior of EG/water ZnO nanofluid in multiport mini channels

Thermal properties measurement and performance evaluation of water/ZnO nanofluid in a mini channel with offset fins

Natural convection heat transfer in concentric annuli with nanofluids

Flow and Heat Transfer Characteristics of Nanofluids Containing Rod-Like Particles in a Turbulent Pipe Flow

Machine Learning Assisted Microchannel Geometric Optimization—A Case Study of Channel Designs

Dynamic viscosity prediction of nanofluids using artificial neural network (ANN) and genetic algorithm (GA)

Thermal conductivity modeling of nanofluids with ZnO particles by using approaches based on artificial neural network and MARS

Enhancing performance of nanofluid mini-channel heat sinks through machine learning and multi-objective optimization of operating parameters

Artificial neural network and numerical analysis for performance enhancement of hybrid microchannel-pillar-jet impingement heat sink using Al2O3-water and CuO-water nanofluids

Heat transfer and pressure drop of Al 2 O 3 /water nanofluid in conically coiled tubes: Experimental and artificial neural network prediction

Turbulent heat transfer and flow analysis of hybrid Al2O3-CuO/water nanofluid: An experiment and CFD simulation study

Heat Transfer Analysis of Different Coolant in the Waist Tubes of a Radiator and Performance Prediction Based on Artificial Neural Network

Experimental Performance Evaluation and Artificial-Neural-Network Modeling of ZnO-CuO/EG-W Hybrid Nanofluids

Thermal conductivity prediction of WO 3 -CuO-Ag (35:40:25)/water hybrid ternary nanofluid with Artificial Neural Network and back-propagation algorithm

Heat transfer and flow features of Al2O3-water nanofluids flowing through a circular microchannel - Experimental results and correlations

Artificial neural network modeling of thermal characteristics of WO 3 -CuO (50:50)/water hybrid nanofluid with a back-propagation algorithm

Reduced order modelling of natural convection of nanofluids in horizontal annular pipes based on deep learning

Numerical investigation of thermal performance augmentation of nanofluid flow in microchannel heat sinks by using of novel nozzle structure: sinusoidal cavities and rectangular ribs

A novel neural network and sensitivity analysis method for predicting the thermal resistance of heat pipes with nanofluids