Abstract:This study investigates the alternative of replacing noble metals by base metals as catalysts for selective hydrogenation of polyunsaturated hydrocarbons. Nickel catalysts are active for this type of reaction, but poorly selective. However, former calculations anticipated that Ni–Zn alloys could have higher selectivity to alkenes than monometallic Ni depending on the Ni/Zn atomic ratio in the alloy. In this contribution, Ni–Zn alloy nanoparticles supported on TiO2 are synthesized as catalysts for selective hydrogenation of acetylene and butadiene. The designed catalysts with 0.5 wt% Ni loading and various Ni/Zn nominal ratios are prepared by deposition–precipitation with urea (DPU). STEM-HAADF imaging coupled with EDS analysis reveals that Ni–Zn bimetallic particles are formed after reduction treatment at 450 °C. Alloying Ni with Zn leads to a slight increase in the average particle size and a broadening of the size distribution compared to monometallic Ni. However, the average Ni/Zn atomic ratio measured by EDS in the bimetallic particles is always higher than the nominal one, which could be due to Zn evaporation under the beam. The results of acetylene hydrogenation show that although the catalytic activity is slightly reduced after alloying Ni with Zn, the selectivity to ethylene is enhanced from 50% up to 85%, at the expense of the formation of oligomers (coupling products). However, the bimetallic Ni–Zn catalysts suffer from progressive deactivation in this reaction. During butadiene hydrogenation performed in the presence of an excess of propene, the bimetallic Ni–Zn/TiO2 catalysts are significantly more stable, with a high and constant selectivity to butenes (> 95%), compared with Ni/TiO2, which deactivates rapidly in the first hours. Some hypotheses concerning the observed differences in catalytic stability are discussed.

A comparison of Ni, Pt, and NiPt catalysts supported on SBA-15 in anisole hydrodeoxygenation: Exploring the effect of platinum addition to a nickel catalyst

Hydrodeoxygenation of anisole over SBA-15-supported Ni, Pd, and Pt mono- and bimetallic catalysts: effect of the metal's nature on catalytic activity and selectivity

Study on the Ni Supported Catalysts Used for Hydrogenation of IPN to Produce MXDA

Liquid-Phase Hydrogenation of Nitrobenzene over Ag-Ni Bimetallic Catalysts Prepared by Adsorption Phase Synthesis

Searching for the optimum Pt loading in bimetallic PtXNi/SBA-15 catalysts for hydrodeoxygenation

Bimetallic Niobium-Based Catalysts Supported on SBA-15 for Hydrodeoxygenation of Anisole

An efficient bifunctional Ni-Nb2O5 nanocatalysts for the hydrodeoxygenation of anisole

Boosting the Hydrodeoxygenation Activity and Selectivity of Ni/(M)-SBA-15 Catalysts by Chemical Alteration of the Support

NiO x -promoted Cu-based catalysts supported on AlSBA-15 for chemoselective hydrogenation of nitroarenes

Effect of Oxide Supports in Stabilizing Desirable Pt-Ni Bimetallic Structures for Hydrogenation and Reforming Reactions

Investigations into the influence of nickel loading on MoO 3 -modified catalysts for the gas-phase hydrodeoxygenation of anisole

Synthesis of bimetallic Ni-Pt/SAPO-11 composite and the catalytic application in n-heptane hydroisomerization

Activity, selectivity and stability of Ni and bimetallic Ni–Pt supported on zeolite Y catalysts for hydrogenation of acetophenone and its substituted derivatives

Bimetallic Ni–Zn/TiO2 catalysts for selective hydrogenation of alkyne and alkadiene impurities from alkenes stream

Insights into the Nature of Selective Nickel Sites on Ni/Al 2 O 3 Catalysts for Propane Dehydrogenation

Perovskite-Derived Pt–Ni/Zn(Ni)TiO3/SiO2 Catalyst for Propane Dehydrogenation to Propene

Sulfured NiMo catalysts on TiO2-Nb2O5 nanocomposites for efficient hydrodesulfurization performance

Preparation and Catalytic Activity of Monolayer Dispersed Pt/Ni Bimetallic Catalyst for C = C and C = O Hydrogenation

Catalytic performance of supported Ni in the hydrodesulfurization of dibenzothiophene

Temperature-Dependent Hydrogenation, Hydrodeoxygenation, and Hydrogenolysis of Anisole on Nickel Catalysts

The effect of surface acidic and basic properties on the hydrogenation of aromatic rings over the supported nickel catalysts