Abstract:The present article investigates the interactions between the pilot and main flames in a novel stratified swirl burner using both experimental and numerical methods. Experiments are conducted in a test rig operating at atmospheric conditions. The system is equipped with the BASIS (Beihang Axial Swirler Independently-Stratified) burner fuelled with premixed methane-air mixtures. To illustrate the interactions between the pilot and main flames, three operating modes are studied, where the burner works with: (i) only the pilot flame, (ii) only the main flame, and (iii) the stratified flame (with both the pilot and main flames). We found that: (1) In the pilot flame mode, the flame changes from V-shape to M-shape when the main stage is switched from closed to supplying a pure air stream. Strong oscillations in the M-shape flame are found due to the dilution of the main air to the pilot methane flame. (2) In the main flame mode, the main flame is lifted off from the burner if the pilot stage is supplied with air. The temperature of the primary recirculation zone drops substantially and the unsteady heat release is intensified. (3) In the stratified flame mode, unique beating oscillations exhibiting dual closely-spaced frequencies in the pressure spectrum. is found. This is observed within over narrow window of equivalence ratio combinations between the pilot and main stages. Detailed analysis of the experimental data shows that flame dynamics and thermoacoustic couplings at these two frequencies are similar to those of the unstable pilot flame and the attached main flame cases, respectively. Large Eddy Simulations (LESs) are carried out with OpenFOAM to understand the mechanisms of the time averaged flame shapes in different operating modes. Finally, a simple acoustic analysis is proposed to understand the acoustic mode nature of the beating oscillations.

Spray Swirling Flame Dynamic under Combined Modulation of Air and Fuel

Multi-bifurcation behaviors of stability regimes in a centrally staged swirl burner

Experimental Study on Self-Excited Thermoacoustic Instabilities and Intermittent Switching of Azimuthal and Longitudinal Modes in an Annular Combustor

Experimental Investigation on High Frequency Perturbation to Combustion Instability by Low Frequency Actuator in a Backward-facing Step Combustor

Experimental study of stratified swirl flame dynamics in a model gas turbine combustor

Flame dynamics and oscillation characteristics based on statistical analysis in a combustor with prefilming and non-prefilming atomization

Flame interactions in a stratified swirl burner: flame stabilization, combustion instabilities and beating oscillations

Flame dynamics and combustion instability induced by flow-flame interactions in a centrally-staged combustor

Flame radiation feedback to fuel surface in medium ethanol and heptane pool fires with cross air flow

Experimental investigation of combustion instability in a centrally staged combustor under self-excited oscillation conditions

Spray flames in an air-heptane swirling combustor

ICOPE-15-C047 Dynamics of Non-premixed Flames with Modulations in the Air Flow for a Bluff-body Burner

Supercritical bifurcations and nonlinear mode interactions of combustion instabilities in a centrally-staged swirl spray combustor

Experimental Investigation on the Symmetry and Stabilization of Ethanol Spray Swirling Flames Utilizing Simultaneous PIV/OH-PLIF Measurements

Flame visualization and spectral analysis of combustion instability in a premixed methane/air-fueled micro-combustor

Instability Behaviors and Suppression of the Unsteady Autoignited Turbulent Jet Flame in Hot Coflow

Interaction Between Self-Excited Oscillations and Fuel–air Mixing in a Dual Swirl Combustor

Active suppression of swirl-stabilized combustion instability

Blowout Dynamics and Plasma-Assisted Stabilization of Premixed Swirl Flames under Fuel Pulsations

Experimental investigation on the effects of transverse injection distribution scheme on dual flame dynamics subjected to flow disturbances

Flame stabilization of liquid oxygen/kerosene bi-swirl injector at elevated pressure