Abstract:Volatile organic compounds (VOCs) are one of the major components of air pollution. Catalytic combustion is a promising technology for the treatment of VOCs and at its center is the preparation of efficient and cheap catalysts. In this study, by loading copper (Cu) and manganese (Mn) on Santa Barbara Amorphous-15 (SBA-15) molecular sieve, the Cu x –Mn y /SBA-15 ( x = 1, 2; y = 1, 2) composite metal oxide catalyst was prepared using the equal volume impregnation method. Their performance in the toluene catalytic combustion reaction was investigated by adjusting the molar ratio ( x : y ), and the loading of Cu and Mn. The results of the Brunner–Emmett–Teller (BET), X-ray diffraction (XRD), scanning electron microscopy (SEM), and X-ray photoelectron spectroscopy (XPS) analyses show that the CuMnO spinel phase can be detected in the Cu–Mn composite metal oxide catalyst doped with a low concentration of Cu. The overall rod-like structure of the fibrous network structure provides a large specific surface area, and the particle crystallinity is low and the dispersion is good. Due to the synergistic effect of Cu and Mn, the greater the amount of Mn 3+ and adsorbed oxygen species (O ads ) that are available, and the higher the turnover frequency (TOF) value, the better and more superior catalytic performance and excellent stability is obtained, when compared with the single-component oxides used in toluene catalytic combustion. After a continuous catalytic reaction for 12 h, the toluene conversion rate remained above 95%. The coupling effect of the catalytic reaction temperature and concentration of oxygen on the catalytic combustion of toluene was also studied. At a low reaction temperature (<250 °C), the increase of the concentration of oxygen played a superior role in promoting the conversion of toluene. The kinetic analysis of the toluene catalytic combustion process showed that the catalytic combustion of toluene by Cu–Mn/SBA-15 followed both the Mars–Van Krevelen (MVK) and Langmuir–Hinshelwood (L–H) reaction mechanisms. With the increase of the O ads amount caused by the decrease of the Cu ratio, the proportion of the L–H reaction mechanism increases.

Mn-Ag Bimetals Supported on Plate-Like ZSM-5 As Efficient and Stable Catalysts for the Catalytic Combustion of Toluene: Synergistic Effects and Catalytic Mechanisms

Ag-Doped δ-MnO 2 Nanosheets as Robust Catalysts for Toluene Combustion

In Situ Fabrication of Highly Active Γ-Mno2/smmno3 Catalyst for Deep Catalytic Oxidation of Gaseous Benzene, Ethylbenzene, Toluene, and O-Xylene.

Adsorption and Catalytic Ozonation of Toluene on Mn/ZSM-5 at Low Temperature

Synergy of Mn and Ni Enhanced Catalytic Performance for Toluene Combustion over Ni-doped Α-Mno2 Catalysts

Boosting Toluene Combustion in Pt-Co3O4 Catalysts by Directional Tuning Strong Metal-Support Interactions Through Metal-Organic Template Pyrolysis

Effect of Ag on toluene oxidation over Ag supported wire-like MnO2 catalysts

Enhanced combustion of toluene on bimetallic-organic frameworks Fe-doped Mn2O3 nanoparticles

Adjusting Ag0 on Oxygen-Deficient Ag/MnO2 Through Electronic Metal-Support Interaction to Enhance Mineralization of Toluene in Post-Plasma Catalytic System

Bimetallic Fe-Mn loaded H-ZSM-5 zeolites for excellent VOCs catalytic oxidation at low-temperatures: Synergistic effects and catalytic mechanisms

Pt-loaded ellipsoidal nanozeolite as an active catalyst for toluene catalytic combustion

Atomically dispersed Ag on δ-MnO2 via cations vacancies trapping for toluene catalytic oxidation

Low-Temperature Combustion of Toluene over Cu-Doped SmMn<sub>2</sub>O<sub>5</sub> Mullite Catalysts via Creating Highly Active Cu<SUP>2+</SUP>-O-Mn<SUP>4+</SUP> Sites

A high-efficiency γ-MnO2-like catalyst in toluene combustion

Enhanced catalytic performance for toluene combustion via Ce-doped α-MnO2: efficient balance between toluene adsorption and activation oxidation

Coupling effect of reaction conditions on the catalytic activity of Cu–Mn composite oxide catalysts for toluene

Modulated synthesis of MnO2-decorated Fe–Mn composite oxides:synergistic effects on boosting the performance of toluene oxidation

Promoted catalytic performance of Ag-Mn bimetal catalysts synthesized through reduction route

ZSM-5 nanocrystal promoted low-temperature activity of supported manganese oxides for catalytic oxidation of toluene

Synergistic mechanism of Ce-Mn in ZSM-5 carrier catalysts for catalytic oxidation of toluene

Supported ceria-modified silver catalysts with high activity and stability for toluene removal