Abstract:The centrally staged combustor is an effective way to reduce pollutant emissions. However, combustion instability is one of the prominent and unavoidable problems for lean premixed combustion. The present paper presents an experimental investigation of combustion instability, flame dynamics and emissions in a three-stage central-graded lean combustion system with strong coupling of inner and outer premixed flames. The flame structure was captured by OH* chemiluminescence images using a high-speed camera. The effects of stratified ratios (SR) under different thermal powers on the thermoacoustic oscillations, flame dynamics and emissions are analyzed. The results indicate that the effect of stratification ratio on thermoacoustic instability, flame dynamics, and emission characteristics is significantly different at various thermal powers. Limit circle oscillations are more likely to occur under high thermal power conditions, and an increase in the stratification ratio leads to a shift in the flame structure from an M-shaped, two-branch stratified flame structure to a V-shaped structure. At low thermal power, a change in the stratification ratio does not lead to a shift in the flame structure, and heat release is enhanced with an increase in the stratification ratio and accompanied by a thermoacoustic state that becomes unstable. In this study of central stratified combustion featuring tightly coupled inner and outer flames, the thermoacoustic instability is closely associated with the dynamic characteristics of the flames. Three unstable combustion mechanisms are identified and confirmed. The interactions between the inner and outer flames, the main shear layer flame and the wall, as well as the inner and outer shear layer flames, are the primary causes inducing instability in the unstable V-shaped flames, the M-shaped flames, and the two-branched stratified flame, respectively. Emission measurements show that under low thermal power conditions, the out-enriched flame primarily leads to elevated CO emission levels, with a limited impact on NO emissions. Conversely, the enrichment of the inner flame contributes significantly to an increase in NO emissions.

Study on Combustion Instability of Secondary Combustion in an Axial Staged Model Combustor

Spray Swirling Flame Dynamic under Combined Modulation of Air and Fuel

Experimental Investigation on High Frequency Perturbation to Combustion Instability by Low Frequency Actuator in a Backward-facing Step Combustor

Experimental Study on Self-Excited Thermoacoustic Instabilities and Intermittent Switching of Azimuthal and Longitudinal Modes in an Annular Combustor

Multi-bifurcation behaviors of stability regimes in a centrally staged swirl burner

Experimental study on thermoacoustic performance of radial staged combustor

Experimental investigation of combustion instability in a centrally staged combustor under self-excited oscillation conditions

Combustion Instability Analysis on a Partially Premixed Swirl Combustor by Thermoacoustic Experiments and Modeling

Active Control of Low-Frequency Combustion Instabilities in a Dump Combustor

Influence of the co- and counter-swirl on combustion instability of the centrally staged combustor

Thermoacoustic Instabilities with Varying Geometries of the Main-Stage Exit in a Centrally Staged Burner

Experimental Study on Combustion Instability of Lean Premixed Swirl Flame

Flame dynamics and combustion instability induced by flow-flame interactions in a centrally-staged combustor

Experimental Study of the Effect of Outlet Boundary on Combustion Instabilities in Premixed Swirling Flames

Flame visualization and spectral analysis of combustion instability in a premixed methane/air-fueled micro-combustor

Tangential Mode Combustion Oscillation of a Bluff-Body-Stabilized Diffusion Flame: Experiments

Mutual Synchronization and Flame Dynamics in an Axially Fuel-Staged Lean-Premixed Combustion System

Experimental Investigation on the Effect of Inlet Temperature on Thermoacoustic Oscillation in a Centrally-Staged Combustor

Supercritical bifurcations and nonlinear mode interactions of combustion instabilities in a centrally-staged swirl spray combustor

Self-Excited Second-Order Azimuthal Thermoacoustic Instabilities in an Annular Combustor with Oblique-Injecting Swirling Burners

Interaction among Flame Structures and Thermoacoustic Instabilities in a Centrally Staged Combustor