Abstract:Palladium has long been explored for use in gas sensors because of its excellent catalytic properties and its unique property of forming hydrides in the presence of H2. However, pure Pd-based sensors usually suffer from low response and a relatively high limit of detection. Palladium nanosheets (PdNS) are of particular interest for gas sensing applications due to their high surface area and excellent electrical conductivity. Here, we demonstrate the design and fabrication of low-cost PdNS-based dual gas sensors for room-temperature detection of H2 and CO over a wide concentration range. We fabricated sensors using multiwalled carbon nanotube@PdNS (MWCNT@PdNS) composites and compared their performance against pure PdNS devices for hydrogen sensing based on electrical resistive response. Devices using PdNS alone had a response and response time of 0.4% and 50 s, respectively, to 1% H2 in air. MWCNT@PdNS (1:5 mass ratio) showed enhanced performance at a lower hydrogen concentration with a limit of detection (LODH2) of 5 ppm. Nearly an order of magnitude increase in response was observed on increasing the amount of MWCNT to 50 mass % in the nanocomposite, but the response fell off at low H2 concentration. Overall, these PdNS-based sensors were found to show good repeatability, stability, and performance under humid conditions. Their response was selective for H2versus CH4, CO2, and NH3; the response to CO was comparable in magnitude but opposite in sign to the response to H2. Upon simultaneous exposure to equal concentrations (10 ppm each) of H2 and CO, the response to CO was dominant. The PdNS showed high sensitivity to CO, detecting as little as 1 ppm CO in air at room temperature. The sensitivity to CO could be used either in a stand-alone room-temperature CO detector, where H2 is known not to be present, or in combination with CO and combustible gas detectors to distinguish H2 from other combustible gases.

Enhanced PtRu by CeO2 hollow nanofibers: Hydrogen gas sensing with CO-resistant in fuel cell

Carbon Monoxide-Resistant Hydrogen Detection: Pt–Melamine–Formaldehyde with Portable Bluetooth in Fuel Cell

Ru Modulates the Catalytic Activity of Pt to Modify WO3 Nanowires for High-Performance Hydrogen Sensing at Near Room Temperature

Pt Loading of Phosphorus-Doped Carbon Nanotube Aerogels in Fuel Cell-Type Gas Sensors for Ultrasensitive H2 Detection

Improved Sensitivity of α-Fe2O3 Nanoparticle-Decorated ZnO Nanowire Gas Sensor for CO

Pt/SnO 2 -Pd nanoelectrode applied for hydrogen sensor with zero-power consumption and low detection limit

Study of a New Hydrogen Gas Sensor Synthesized With a Sputtered Cerium Oxide Thin Film and Evaporated Palladium Nanoparticles

Cobalt Nanoparticles and Atomic Sites in Nitrogen-Doped Carbon Frameworks for Highly Sensitive Sensing of Hydrogen Peroxide.

Inhibiting Emulative Oxygen Adsorption via Introducing Pt-Segregated Sites into the Pd Surface for Enhanced H2 Sensing in Air

Enhancement of H2 Gas Sensing Using Pd Decoration on ZnO Nanoparticles

High Response and ppb-Level Detection toward Hydrogen Sensing by Palladium-Doped α-Fe2O3 Nanotubes

High Response and ppb-Level Detection toward Hydrogen Sensing by Palladium-Doped α-Fe 2 O 3 Nanotubes

CeO2 nanorods decorated In2O3 nanoparticles for enhanced low temperature detection of hydrogen

Metal Nanocluster—Metal Organic Framework—Polymer Hybrid Nanomaterials for Improved Hydrogen Detection

Metal Oxide Nanowire-Based Sensor Array for Hydrogen Detection

Palladium Nanosheet-Based Dual Gas Sensors for Sensitive Room-Temperature Hydrogen and Carbon Monoxide Detection

High-Selectivity Hydrogen Gas Sensors based on Mesoporous PbOx-ZnO Nanocomposites

Low detection based on Pd Pt /In2O3 nanospheres for rapid hydrogen detection

Micellar Nanoreactors Enabled Site-Selective Decoration of Pt Nanoparticles Functionalized Mesoporous SiO2 /Wo3-X Composites for Improved CO Sensing.

Dual Mechanisms of Pd-Doped In 2 O 3 /CeO 2 Nanofibers for Hydrogen Gas Sensing

A Fuel-Cell-Type Sensor for Detection of Carbon Monoxide in Reformed Gases