Abstract:Reaction processes of decomposition and partial oxidation of a mixture of acid gas (H2S and CO2) and methane (CH4) could enable the efficient production of valuable syngas resource (H-2 and CO). In this work, the decomposition and partial oxidation of H2S-CH4-CO2 system was experimentally studied in a tube furnace. Effects of temperature, CH4 and CO2 addition, equivalence ratio and residence time were studied for syngas production and H-2/CO variation. Extended temperature and pressure were then studied by equilibrium calculation for thermodynamic analysis in Aspen Plus software. The results showed the increasing temperature favored reactant conversion and syngas production. H2S decomposition was the dominant reaction at temperature below 1050 C-degrees while threshold temperature for CH4 conversion over H2S was about 1100 C-degrees. H-2 was formed mainly via H2S decomposition at low temperatures. CH4 addition promoted H-2 formation and conversely restrained H2S conversion. The introduction of O-2 brought partial oxidation, favored the reaction rate, balanced H-2/CO but reduced syngas production. H-2/CO ratio also remained at an appropriate level at high CO2 addition since CO2 evidently adjusted the ratio via CO2+H-2 CO + H2O. However, this CO2 reactivity was only adequately expressed under high temperature and extended residence time. Equilibrium calculation confirmed experimental variation trends and revealed reducing pressure favored the syngas production. It could be inferred that extended residence time, higher temperature, suitable equivalence ratio, CH4 and CO2 addition and low pressure could enable improvement in both syngas production and H-2/CO. This study revealed high syngas production and adjustment of H-2/CO could be realized in H2S-CH4-CO(2 )system and this might be of great practical in industry.

Investigation of Decomposition and Partial Oxidation of Mixed Acid Gas and Methane for Syngas Production

Non-catalytic Direct Conversion of CH4 and CO2 into High-Quality Syngas

Kinetic Study of Decomposition of H2s and Ch4 for H-2 Production Using Detailed Mechanism

Equilibrium Prediction of Acid Gas Partial Oxidation with Presence of Ch4 and Co2 for Hydrogen Production

Process Analysis of Methane Simultaneous Oxidative Conversion to Syngas Based on Symbiosis Theory

Thermodynamic Study on the Catalytic Partial Oxidation of Methane to Syngas

Syngas Production by Simultaneous Splitting of H2o and Co2 Via Iron Oxide (fe3o4) Redox Reactions under High-Pressure

Experimental Study and Numerical Simulation of Producing Syngas from Coke Oven Gas by Non-Catalytic Partial Oxidation

Thermodynamic Reaction Study of Conversion of H2S and CO2 and the Promoting Effect of Light on the Reaction

Thermal decomposition of magnesium carbonate in methane atmosphere for the synthesis of syngas: The effect of O 2

Preparation of Syngas from Partial Oxidation of Bio-Oil

Syngas Production Via Ce0.8Zr0.2O2-based Thermochemical Co-Splitting of H2O and CO2 and Partial Oxidation of Methane: Achieving a 2:1 H2/CO Ratio

Syngas Production by Integrating CO2 Partial Gasification of Pine Sawdust and Methane Pyrolysis over the Gasification Residue

Non-catalytic Partial Oxidation of Simulating Coke Oven Gas to Syngas

Detailed Kinetic Modelling of H2s Oxidation with Presence of Co2 under Rich Condition

Optimization and analysis of syngas production from methane and CO2 via Taguchi approach, response surface methodology (RSM) and analysis of variance (ANOVA)

Preparation of Syngas from Natural Gas by Non-Catalytic Partial Oxidation

Optimization of syngas production by non-catalytic partial oxidation of coke oven gas

Combined Steam/dry Reforming of Bio-Oil for H2/CO Syngas Production with Blast Furnace Slag As Heat Carrier

New Process of High-Quality Syngas Production Through Sequential Oxidation–Reduction Cycles of Pulverized Coals

Ch4-Rich Gas In Coke Oven Gas Partial Oxidation For Producing Syngas With Coke Or Semi-Coke Support