Abstract:A supercritical carbon dioxide (S-CO2) and Organic Rankine Cycle (ORC) combined cycle has been considered to fully use the residual heat of a high temperature heat source in this paper. The topping cycle is a S-CO2 recompression cycle, and the bottoming cycle is an ORC with R245fa as the working fluid. Compared with previous studies, the influence of several additional parameters, including the S-CO2 recompression cycle main compressor inlet temperature and pressure and the S-CO2 recompression cycle split ratio, has been conducted. It indicates that the split ratio plays an important role on the S-CO2 recompression cycle, even on the combined cycle. A thermodynamic optimization method which considers the split ratio is proposed to maximum the combined cycle thermal efficiency. By this method, more than 4.1% increment on the thermal efficiency can be attained. INTRODUCTION The supercritical carbon dioxide (S-CO2) is a special kind of CO2 fluid whose temperature and pressure are higher than its critical values (304.13K, 7.38 MPa). The S-CO2 cycle, which uses S-CO2 as the working fluid, is considered to be one of the most promising power generation technologies for the future (Feher, 1968). The S-CO2 cycle has higher efficiency and more compact system and components than conventional power cycles, especially in the high temperature range. Besides, CO2 is easy to obtain and the S-CO2 cycle system has high safety level. It is widely acknowledged that the S-CO2 cycle is applicable for various heat sources, such as the nuclear energy (Moisseytsev and Sienicki, 2009), concentrated solar power (Turchi and Ma, 2012), fuel cell (Xia et al., 2019) and waste heat recovery (Song et al., 2018a). One of the S-CO2 cycle characteristics is that the specific heat capacity of the cold side flow is much higher than that of the hot side in recuperators. For the S-CO2 recompression cycle, the CO2 flow is split to compensate for the specific heat difference in the low temperature recuperator and to further enhance the heat recuperation in the high temperature recuperator. Therefore, the residual heat is decreased and the S-CO2 recompression cycle has higher efficiency than simple recuperated cycle. The S-CO2 recompression cycle has been adopted by National Energy Technology Laboratory (NETL) of U.S. DOE for Supercritical Transformational Electric Power (STEP) program (Lambruschini et al., 2016).

Thermodynamic and Exergoeconomic Analysis of a Dual Expansion and Triple Recuperation Supercritical CO2 Power Cycle Driven by DME-oxygen Combustor

Performance Analysis and Evaluation of a Supercritical CO2 Rankine Cycle Coupled with an Absorption Refrigeration Cycle

Theoretical Analysis on Thermodynamic and Economic Performance Improvement in a Supercritical CO2 Cycle by Integrating with Two Novel Double‐Effect Absorption Reheat Power Cycles

Simulation of DME-O 2 Combustion in a Hollow Cone Impinging Jet Combustor for Direct-Fired Supercritical CO 2 Power Cycle

Simulation of DME-O2 Combustion in a Hollow Cone Impinging Jet Combustor for Direct-Fired Supercritical CO2 Power Cycle

Exergoeconomic Analysis of Utilizing the Transcritical CO2 Cycle and the ORC for a Recompression Supercritical CO2 Cycle Waste Heat Recovery: A Comparative Study

Thermodynamic evaluation and optimization of supercritical CO 2 Brayton cycle considering recuperator types and designs

Exergy and Exergoeconomic Analyses of A Supercritical Co2 Cycle for A Cogeneration Application

Advanced Exergoeconomic Evaluation on Supercritical Carbon Dioxide Recompression Brayton Cycle

Thermodynamic Analysis and Optimization of a Supercritical Carbon Dioxide (S-CO2) Recompression Cycle Coupled with a Bottoming Organic Rankine Cycle

Thermo-Economic Analysis Of A Recompression Supercritical Co2 Cycle Combined With A Transcritical Co2 Cycle

Thermo-economic analysis and multi-objective optimization of supercritical Brayton cycles with CO2-based mixtures

Exergoeconomic Analysis and Optimization of Single-Pressure Single-Stage and Multi-Stage CO2 Transcritical Power Cycles for Engine Waste Heat Recovery: A Comparative Study

Off-design Behavior Investigation of the Combined Supercritical CO2 and Organic Rankine Cycle

Thermodynamic assessment of a novel and efficient self-condensing transcritical CO 2 power cycle with a vortex tube

Thermodynamic, Economic Analysis and Multi-Objective Optimization of an Improved Self-Condensing Transcritical CO2 Rankine Cycle with Two-Stage Ejector for Low Grade Heat Utilization

Evaluation and optimization of supercritical cycles using CO 2 based mixtures as working fluids: A thermodynamic study

Thermodynamic and Economic Analysis and Multi-objective Optimization of Supercritical CO2 Brayton Cycles

Thermodynamic, economic analysis and multi-objective optimization of an improved self-condensing transcritical CO 2 Rankine cycle with two-stage ejector for low grade heat utilization

Thermodynamic and exergoeconomic analysis of combined supercritical CO2 cycle and organic Rankine cycle using CO2-based binary mixtures for gas turbine waste heat recovery

Thermodynamic Analysis for a Novel Combined Power and Refrigeration Cycle Using Trans-Critical CO2