Abstract:Superheated droplets vaporized in a vacuum or vapor chamber was studied using smoothed particle hydrodynamics method.The two-phase fluids of vapor and liquid with a diffused interface were modeled by Navier-Stokes-Korteweg equations,with the van der Waals equation of state.The liquid-vapor separation was processed with different initial temperature and density.Simulation was firstly validated by the proper equilibrium states with analytical data from the binodal line of Maxwell construction,as well as the droplet surface tension compared with experimental and other groups'numerical data in a good agreement.Droplet morphology,density,temperature and entropy increment were then carefully examined during the dynamic process from evaporation to boiling.Four phase transitions patterns were concluded,namely from surface evaporation,internal bubble,fragment and explosion,to flash boiling with increasing equivalent superheat degree that is defined by the non-dimensional superheat temperature over surface tension.Results showed that droplet temperature and density decreased slightly at surface evaporation when equivalent superheat degree was lower than 1/3.Above this criterion,the internal bubble could be sustained.Growth of new liquid nucleates and connected secondary liquid ring were calculated by domain growth theory.We found that droplet continuous to expand at high superheat but withdrawn at equivalent superheat degree equal to or lower than 0.52.At equivalent superheat degree higher than 1,the growth and expansion of droplet resulted in liquid fragment and explosion to many small secondary droplets.Mean mass and diameter of these droplets were found to have power-law dependency on the expansion rate.Finally,fast flash boiling occurred at equivalent superheat degree higher than 3.The vapor pressure in the chamber showed a negative linear correlation between the overpressure and the atmospheric pressure.We also found out that comparing to increase the pressure value,dense gas had better efficiency on retarding the propagation of shock wave.

Coupling Effect Between Film Boiling Heat Transfer and Evaporation Drag Around a Hot-Particle in Cold Liquid

Experimental Study on the Boiling Movement Process of the High-temperature Particles Falling into the Cold Liquid

An Experimental Study on the Drag Property of High Temperature Particles Falling into Cold Liquid Pool

An Experimental Study on the Movement Mechanism of the High-Temperature Particles Falling into the Coolant Pool

Droplet Evaporation to Boiling in Van Der Waals Fluid

Evaporation Drag Model of High Temperature Particles Moving Inside Coolant

Coupling droplets/bubbles with a liquid film for enhancing phase-change heat transfer

Experimental Investigation on the Dynamic Characteristics of Molten Droplets and High-Temperature Particles Falling in Coolant

Experimental study of heat and dynamic characteristics of hot particles moving in coolant under film boiling condition

Drag reduction characteristics of heated spheres falling into water

Boiling effect of liquid droplet under high temperature radiation

Effect of evaporation rate for the heat and mass transfer of the laminar liquid falling film in still air

The effect of foreign particles on liquid film evaporation at the nanoscale: A molecular dynamics simulation

Experimental Investigation of Dynamic Evaporation Characteristics of Liquid Droplet on Heated Surface

Dynamic Characteristics of Molten Droplets and Hot Particles Falling in Liquid Pool

The Effect of Interfacial Evaporation on Heat and Mass Transfer of Falling Liquid Film

Experimental study of two-phase heat transfer of droplet impact on liquid film

Coupling Effect Of Interfacial Transport On Particle-Surface Capillary Forces

Experiment Design of Mechanism Study During Coarse Mixing Stage of Vapor Explosion

A Model of Film Boiling Thermal Hydraulics on a Hot Particle Dropping in Coolant Liquid

Theoretical and Numerical Studies of Liquid Lens Evaporation with Coupled Fields