Abstract:The characteristics of 16Ah nickel-cobalt-manganese (523) square soft-pack lithium-ion battery (16Ah NCM523) during typical thermal runaway (TR) process under abusive conditions including heat, overcharge, and mechanical stress were studied. The heat TR experiment of lithium battery with heating plate as heat source shows that the temperature of 16Ah NCM523 escalates from 19.9 °C to 62 °C. The TR of 16Ah NCM523 occurs violently, and the temperature of the soft package burst is 96.4 °C. And the voltage sag time during this TR of 16Ah NCM523 obviously laged behind the heat production characteristics of the battery. The results of overcharged TR of 16Ah NCM523 shows that the temperature of 16Ah NCM523 rises andante with a rate not higher than 1°C/s and then reaches 98.5 °C. Following, the temperature of battery increases rapidly to 481.2 °C. During overcharged TR of 16Ah NCM523, the voltage begins to drop rapidly 2 s earlier than temperature change, which means that voltage and temperature can be used as early warning signals of overcharged TR. For the nail penetration TR of 16Ah NCM523, at the moment of mechanical abuse, the battery bulges and erupts gas. At the same time, the voltage of 16Ah NCM523 drops to zero in a very short time (<5s), and the temperature rises rapidly to 477.5 °C, which means voltage, temperature and gas can be used as early warning signals when machinery is abused, but the reserved response time is short. Simulation approaches are employed to analyze the thermal runaway phenomena. The simulation results show good agreement with the experimental results. Among the abuse conditions, it is observed that nail penetration leads to the fastest TR, followed by heating, and finally overcharged. The heat inside the 16Ah NCM523 mainly comes from the reaction heat Q neg of negative active material and electrolyte, the decomposition reaction heat Q sei of SEI film, the reaction heat Q pos of positive active material and electrolyte, and the decomposition reaction Q ele of electrolyte. The main inducing factors of internal thermal reaction of 16Ah NCM523 are different with different thermal runaway.

Experimental Study on the Thermal Runaway Acceleration Mechanism and Characteristics of NCM811 Lithium-Ion Battery with Critical Thermal Load Induced by Nail Penetration

Experimental Study on the Thermal Runaway and Flame Dynamics of NCM811 Lithium-Ion Batteries with Critical Thermal Load under Variable Penetration Condition

Experimental Study on Effect of State of Charge on Thermal Runaway Characteristics of Commercial Large-Format NCM811 Lithium-Ion Battery

Experimental and Modeling Analysis of Thermal Runaway for LiNi0.5Mn0.3Co0.2O2/graphite Pouch Cell under Adiabatic Condition

Research on the Thermal Runaway Mechanism and Eruption Flame Dynamics of NCM811 Lithium-Ion Battery Stimulated by the Coupling Abuse of Heat and Penetration

Experimental study on thermal runaway propagation characteristics of NCM811 lithium-ion batteries with different SOCs induced by dual heat sources

Experimental Investigation of Thermal Runaway Characteristics of Large-Format Li(Ni0.8Co0.1Mn0.1)O2 Battery under Different Heating Powers and Areas

Research on Thermal Runaway Characteristics and Mechanism of NCM811 Lithium-ion Batteries under Cross-Seasonal and Wide-Temperature Condition at −10 °C ∼ 33 °C: A Case Study in Qingdao, China

Experimental Investigation on the Thermal Runaway and Its Propagation in the Large Format Battery Module with Li(Ni1/3Co1/3Mn1/3)O-2 As Cathode

Thermal Runaway-Induced Current Interrupt Device and Vent Activation Behaviour in an 18650 Lithium-Ion Battery Cap Using the Johnson-Cook Criterion

A Comprehensive Study of Thermal Runaway Behavior and Early Warning Subjected to Internal Short-Circuit

Experimental investigation of thermal runaway in 40Ah prismatic lithium batteries at different SOC

Experimental Study of Thermal Runaway Process of 50 Ah Prismatic Nickel-Rich Battery

Experimental and Modeling Analysis of Thermal Runaway for LiNi0.5Mn0.3Co0.2O2/Graphite Pouch Cell Triggered by Surface Heating

Research on the thermal runaway characteristics and risks of square soft lithium‐ion batteries nail penetration

Experimental and simulated study of thermal runaway characteristics of 16Ah nickel-cobalt-manganese (523) square soft-pack lithium-ion battery

An investigation on thermal runaway behaviour of a cylindrical lithium-ion battery under different states of charge based on thermal tests and a three-dimensional thermal runaway model

Research on Thermal Runaway Process of 18650 Cylindrical Lithium-Ion Batteries with Different Cathodes Using Cone Calorimetry

Thermal Runaway Behaviors and Kinetics of NCM Lithium-Ion Batteries at Different Heat Dissipation Conditions

Experimental Study on Thermal Runaway Behavior of Lithium-Ion Battery and Analysis of Combustible Limit of Gas Production

Thermal Runaway Hazards Comparison Between Sodium-Ion and Lithium-Ion Batteries Using Accelerating Rate Calorimetry