Abstract:The leakage accident of molten salt in the thermal storage tank will cause the shutdown and enormous economic losses of Concentrated Solar Power plants. This study investigates the heat transfer and flow characteristic of commercial molten nitrates leaking in the thermal state porous foundation material. The migration width and depth of three molten nitrates, Solar Salt (60 wt% NaNO 3 -40 wt%KNO 3 ), Hitec XL (7 wt% NaNO 3 -45 wt% KNO 3 -48 wt% Ca(NO 3 ) 2 ) and Hitec (7 wt% NaNO 3 -53 wt%KNO 3 -40 wt%NaNO 2 ), are obtained at different operating temperatures. Experimental results indicate that the temperature rising rate of foundation material in the nitrate leaking process has a trend of first increasing rapidly and then decreasing, and then it increases slightly as the depth increases. The temperature rising rate increases obviously with increasing operating temperature of the molten salt. With the increase of the operating temperature, the distances from the storage tank bottom to solid salt in foundation and the total migration depths both increase obviously, while the average migrating widths change slightly. At the same operating temperature, the temperature rising rate of the foundation material where Hitec XL and Hitec salt leak is significantly greater than that with Solar Salt, which is closely related to the melting points of molten salts. The migration depth of Hitec is 95.03% greater than that of Solar Salt and 19.11% larger than that of Hitec XL at the operating temperature of 300°C. Compared with Hitec XL, the leakage of Hitec with a smaller viscosity has a larger temperature rising rate and a wider and deeper transporting range during the leakage process. This work could guide the installation locations of the leak detection devices for high temperature storage tank and the environmental treatment of leaking accident.

Experimental Investigation and X-Ray Computed Microtomography Simulation on Thermal Physical Properties of Foundation Materials after Molten Salt Leakage in the Storage Tank

Experimental Investigation of Migration and Solidification of Molten Salt Leaking Through Tank Cracks

Migration and Phase Change Study of Leaking Molten Salt in Tank Foundation Material

Experimental Study on Migration and Heat Transfer Characteristics of Three Potential Molten Salts Leaking into Tank Foundation Materials

Experimental and Numerical Investigation of Temperature Distribution and Heat Loss of Molten Salt Tank Foundation at Different Scales

Experimental Study on Seepage Flow Characteristics of Leaked Molten Salt in Foundation Fillers in Concentrating Solar Power Plants

Thermal insulation for a high temperature molten salt storage tank in a CSP plant

Experimental Investigation of the Migration and Solidification Characteristics of Solar Salt in Hot Sand Layer of Tank Foundation

Parametric Study on Melting Process of a Shell-and-tube Latent Thermal Energy Storage under Fluctuating Thermal Conditions

Study of Heat Transfer Performance of Insulating Layer of Molten Salt Storage Tank

Analysis of Flowing and Heat Transfer of Commercial Molten Nitrate in Porous Foundation Material

An Experimental Investigation of Temperature Distribution and Heat Loss in Molten Salt Tanks in Concentrating Solar Power Plants

Thermo-Mechanically Coupled Settlement and Temperature Response of a Composite Foundation in Complex Geological Conditions for Molten Salt Tank in Tower Solar Plants

Evaluation on thermal and mechanical performance of the hot tank in the two-tank molten salt heat storage system

Coupled Thermal and Mechanical Dynamic Performances of the Molten Salt Packed-Bed Thermal Energy Storage System

Influence investigation of hot molten salt temperature on operation and mechanical behaviours of latent heat storage tank

Thermal performance analysis of molten salt based on a novel experimental rig

Numerical modeling and parametric study of the heat storage process of the 1.05 MW molten salt furnace

Experimental measurements and XCT based simulation of effective thermal conductivity of stacked ceramsites in molten-salt tank foundation

Effects of molten salt multi-thermophysical properties on performance of the latent heat thermal energy storage system and synergetic optimization investigation

Research and Application of Molten Salts for Sensible Heat Storage