Abstract:The leakage accident of molten salt in the thermal storage tank will cause the shutdown and enormous economic losses of Concentrated Solar Power plants. This study investigates the heat transfer and flow characteristic of commercial molten nitrates leaking in the thermal state porous foundation material. The migration width and depth of three molten nitrates, Solar Salt (60 wt% NaNO 3 -40 wt%KNO 3 ), Hitec XL (7 wt% NaNO 3 -45 wt% KNO 3 -48 wt% Ca(NO 3 ) 2 ) and Hitec (7 wt% NaNO 3 -53 wt%KNO 3 -40 wt%NaNO 2 ), are obtained at different operating temperatures. Experimental results indicate that the temperature rising rate of foundation material in the nitrate leaking process has a trend of first increasing rapidly and then decreasing, and then it increases slightly as the depth increases. The temperature rising rate increases obviously with increasing operating temperature of the molten salt. With the increase of the operating temperature, the distances from the storage tank bottom to solid salt in foundation and the total migration depths both increase obviously, while the average migrating widths change slightly. At the same operating temperature, the temperature rising rate of the foundation material where Hitec XL and Hitec salt leak is significantly greater than that with Solar Salt, which is closely related to the melting points of molten salts. The migration depth of Hitec is 95.03% greater than that of Solar Salt and 19.11% larger than that of Hitec XL at the operating temperature of 300°C. Compared with Hitec XL, the leakage of Hitec with a smaller viscosity has a larger temperature rising rate and a wider and deeper transporting range during the leakage process. This work could guide the installation locations of the leak detection devices for high temperature storage tank and the environmental treatment of leaking accident.

Experimental Study on Migration and Heat Transfer Characteristics of Three Potential Molten Salts Leaking into Tank Foundation Materials

Migration and Phase Change Study of Leaking Molten Salt in Tank Foundation Material

Experimental Investigation of the Migration and Solidification Characteristics of Solar Salt in Hot Sand Layer of Tank Foundation

Experimental Study on Seepage Flow Characteristics of Leaked Molten Salt in Foundation Fillers in Concentrating Solar Power Plants

Experimental Investigation of Migration and Solidification of Molten Salt Leaking Through Tank Cracks

Experimental Investigation and X-Ray Computed Microtomography Simulation on Thermal Physical Properties of Foundation Materials after Molten Salt Leakage in the Storage Tank

Analysis of Flowing and Heat Transfer of Commercial Molten Nitrate in Porous Foundation Material

An Experimental Investigation of Temperature Distribution and Heat Loss in Molten Salt Tanks in Concentrating Solar Power Plants

Experimental and Numerical Investigation of Temperature Distribution and Heat Loss of Molten Salt Tank Foundation at Different Scales

Thermal insulation for a high temperature molten salt storage tank in a CSP plant

Study of Heat Transfer Performance of Insulating Layer of Molten Salt Storage Tank

Research and Application of Molten Salts for Sensible Heat Storage

Molten Salts Tanks Thermal Energy Storage: Aspects to Consider during Design

Experimental study on the blocking effect of metal mesh on seepage of molten salt in tank foundation materials

Experimental study of viscosity characteristics of high-temperature heat transfer molten salts

Thermo-Mechanically Coupled Settlement and Temperature Response of a Composite Foundation in Complex Geological Conditions for Molten Salt Tank in Tower Solar Plants

Thermal performance analysis of molten salt based on a novel experimental rig

Experimental study of viscosity of new kind of molten salt with low melting point

Review on Thermophysical Properties and Corrosion Performance of Molten Salt in High Temperature Thermal Energy Storage

Evaluation on thermal and mechanical performance of the hot tank in the two-tank molten salt heat storage system

On the viscosity of molten salts and molten salt mixtures and its temperature dependence