Abstract:This study focuses on the great challenges for combined cooling and power supply on hypersonic aircrafts. To address the issues of low thermal efficiency and high fuel consumption of heat sink by the existing CO2 supercritical Brayton cycle, a novel fuel-based CO2 transcritical cooling and power (FCTCP) system is constructed. A steady-state simulation model is built to investigate the impacts of combustion chamber wall temperatures and fuel mass flow rates on the FCTCP system. Thermal efficiency of the CO2 transcritical cycle reaches 25.2~32.8% under various combustion chamber wall outlet temperatures and endothermic pressures. Compared with the supercritical Brayton cycle, the thermal efficiency of novel system increases by 54.5~80.9%. It is found from deep insights into the thermodynamic results that the average heat transfer temperature difference between CO2 and fuel is effectively reduced from 153.4 K to 16 K by split cooling of the fuel in the FCTCP system, which greatly enhances the matching of CO2–fuel heat exchange temperatures and reduces the heat exchange loss of the system. Thermodynamic results also show that, in comparison to the supercritical Brayton cycle, the cooling capacity and power generation per unit mass flow rate of working fluid in the FCTCP system increased by 75.4~80.8% and 12.9~51.6%, respectively. The FCTCP system exhibits a substantial performance improvement, significantly enhancing the key characteristic index of the combined cooling and power supply system. This study presents a novel approach to solving the challenges of cooling and power supply in hypersonic aircrafts under limited fuel heat sink conditions, laying the groundwork for further exploration of thermal management technologies of hypersonic aircrafts.

Thermal Behavior of Supercritical Co 2 Inside Scramjet Cooling Channels with Different Structural Parameters

Thermal behavior of supercritical CO<mml:math xmlns:mml="http://www.w3.org/1998/Math/MathML" display="inline" id="d1e1397" altimg="si109.svg"><mml:msub><mml:mrow /><mml:mrow><mml:mn>2</mml:mn></mml:mrow></mml:msub></mml:math> inside scramjet cooling channels with different structural parameters

Study on Combined Thermal Protection Scheme Integrating Supercritical CO2 Regenerative Cooling and Fuel Film Cooling Used for Scramjet Engines

Thermal Behavior Inside Scramjet Cooling Channels at Different Channel Aspect Ratios

Numerical Investigation of Different Heat Transfer Behaviors of Supercritical CO2 in a Large Vertical Tube

Supercritical Heat Transfer of Cryogenic-Propellant Methane in Rectangular Engine Cooling Channels

Inhomogeneous Behavior of Supercritical Hydrocarbon Fuel Flow in a Regenerative Cooling Channel for a Scramjet Engine

Asymmetric Heating and Buoyancy Effects on Heat Transfer of Hydrocarbon Fuel in a Horizontal Square Channel at Supercritical Pressures

Numerical Investigation of Heat Transfer Characteristics of scCO2 Flowing in a Vertically-Upward Tube with High Mass Flux

Experimental study on convection heat transfer of supercritical CO2 in small upward channels

Convection Heat-Transfer Characteristics of Supercritical Pressure RP-3 in Horizontal Microchannels

Numerical Analysis of Convective Heat Transfer Characteristics of Supercritical Hydrocarbon Fuel in Cooling Panel with Local Flow Blockage Structure

A Novel Fuel-Based CO2 Transcritical Cycle for Combined Cooling and Power Generation on Hypersonic Aircrafts

Numerical Investigation of Convective Heat Transfer of Supercritical Hydrocarbon Fuel in a Tube Filled With Porous Media

Controlling the rule of coke depositions of hydrocarbon fuels in channel to intensify heat transfer under supercritical conditions

Study on influence of forced vibration of cooling channel on flow and heat transfer of hydrocarbon fuel at supercritical pressure

Numerical Study on Flow and Heat Transfer of Supercritical Hydrocarbon Fuel in Curved Cooling Channel

Flow and Heat Transfer Characteristics of Supercritical CO2 in a Natural Circulation Loop

Numerical Study on Flow Structure and Heat Transfer of Supercritical CO2 in Tubes with Different Inclination Angles

Thermal behavior in the cracking reaction zone of scramjet cooling channels at different channel aspect ratios

Performance Analysis and Optimization of a Novel S-CO2 Closed-Brayton-cycle-based Thermal Management System for Scramjets