Abstract:<math>{101¯2}</math> twins were introduced into the magnesium (Mg) plate AZ31 via pre-rolling along its transverse direction. The plates, both with and without the pre-induced <math>{101¯2}</math> twins, were subjected to uniaxial tension along different directions. Using crystal plasticity modeling, we found that the strengthening effect of the pre-induced <math>{101¯2}</math> twins on the macroscopic flow stress primarily arised from the increased slip resistance caused by the boundaries, rather than the orientation hardening due to the twinning reorientation (although the latter did make its contribution in some specific loading directions). Besides, the pre-existing <math>{101¯2}</math> twins were found, by both experiments and simulation, to promote the activity of prismatic 〈a〉 and pyramidal 〈c + a〉 in the parent matrix of the material. Further analysis showed that the enhanced non-basal slip activity is related to the <math>{101¯2}</math> twin boundaries' low micro Hall-Petch slope ratios of non-basal slips to basal slip. With the critical resolved shear stress (CRSS) obtained from crystal plasticity modeling and the orientation data from EBSD, a probability-based slip transfer model was proposed. The model predicts higher slip transfer probabilities and thus lower strain concentration tendencies at <math>{101¯2}</math> twin boundaries than that at grain boundaries, which agrees with the experimental observation that the strain localization was primarily associated with the latter. The present findings are helpful scientifically, in deepening our understanding of how the pre-induced <math>{101¯2}</math> twins affect the strength and slip activity of Mg alloys, and technologically, in guiding the design of the pre-strain protocol of Mg alloys.

Understanding the interaction of {10-12} twins and Mg17Al12 precipitates in magnesium alloys via high-resolution electron microscopy

Understanding the Interaction of {10–12} Twins and Mg17Al12 Precipitates in Magnesium Alloys Via High-Resolution Electron Microscopy

Interaction between 10 1 ̄ 2 and 30 3 ̄ 4 twin in magnesium alloy

Crystallography of the precipitates formed on {10-11} twin boundary in MgAl alloys

The Interaction between Mg17Al12 Precipitate and {10–12} Twin in Mg-Al Alloy: A Molecular Dynamics Simulation Study

The Effect of Twin–twin Interaction in Mg 3al 1zn Alloy During Compression

The Interaction between Mg 17 Al 12 Precipitate and {10–12} Twin in Mg-Al Alloy: A Molecular Dynamics Simulation Study

Twinning Behaviors of Mg-Sn Alloy with Basal or Prismatic Mg2Sn

Investigation of Twin–twin Interaction in Deformed Magnesium Alloy

On the interaction of precipitates and tensile twins in magnesium alloys

3D Atomic-Scale Growth Characteristics of {10–12} Twin in Magnesium

Atomic Motion in Mg–3Al–1Zn During Twinning Deformation

The Engulfment of Precipitate by Extension Twinning in Mg–Al Alloy

{10 1 ̄ 2 } twinning nucleation in magnesium assisted by alternative sweeping of partial dislocations via an intermediate precursor

Analysis of {10–12} Twinning Variants’ Selection Behavior During Multi-Directional Compression in Mg–3Al–1Zn Magnesium Alloy

Structural Characteristics of {1¯012} Non-Cozone Twin-Twin Interactions in Magnesium

On the strengthening and slip activity of Mg-3Al-1Zn alloy with pre-induced { 10 1 ̄ 2 } twins

Twin density and twin thickness evolution in sputtered Al–Mg alloys

Intrinsic twin boundary of η-MgZn2 precipitates in the AA7050 aluminium alloy

Twin-twin Geometric Structure Effect on the Twinning Behavior of an Mg-4Y-3Nd-2Sm-0.5Zr Alloy Traced by Quasi-in-situ EBSD

Twinning Behaviour in the Intermetallic Compound Al 18 Cr 2 Mg 3