Abstract:It is crucial to identify the battery's internal short circuit (ISC) for safety. The study aims to explore the effectiveness of ISC detection methods through battery aging. Two types of method are compared in this work: diffusion coefficient calculation based on electrochemical impedance spectroscopy and conventional internal resistance monitoring through algorithms such as recursive least square (RLS). In this work, the frequency-domain P2D model is built to simulate the behavior of the impedance response with different levels of ISC. Then, coin cells are assembled with conductive contaminants to examine the accuracy of the model simulation and the actual influences of the ISC on the impedance. Afterwards, with the proven impedance model and potential influences, the substituted ISC test on commercial 18,650 cells is applied to examine ISC detection based on EIS under different aging statuses. Finally, the conventional internal resistance identification method is used for comparison. The coin cell experimental results in the study indicate that the inception of the ISC mainly alters the low-frequency impedance with much reduced phases, which is also predicted by the model simulation. Similar results with the impacted low-frequency impedance can also be observed in the substituted ISC test for the commercial cells. The diffusion coefficients, the parameter mainly associated with the low-frequency impedance response, increased by 47–143 % as the battery SOH decreased from 100 % to 87 %. In comparison, the internal resistance identification method indicates that the ohmic component is relatively stable after the inception of the ISC. The polarization component of the internal resistance exhibits a significant change as high as 234 %. However, as the battery's SOH decreases, the effectiveness of the polarization resistance fades toward 23 %.

An Aging- and Load-Insensitive Method for Quantitatively Detecting the Battery Internal-Short-circuit Resistance

A Quantitative Method for Early-Stage Detection of the Internal-Short-circuit in Lithium-ion Battery Pack under Float-Charging Conditions

Investigation and comparison of the electrochemical impedance spectroscopy and internal resistance indicators for early-stage internal short circuit detection through battery aging

A battery internal short circuit fault diagnosis method based on incremental capacity curves

Online internal short circuit detection method considering equalization electric quantity for lithium‐ion battery pack in electric vehicles

Online detection of early stage internal short circuits in series-connected lithium-ion battery packs based on state-of-charge correlation

Disturbance-Immune and Aging-Robust Internal Short Circuit Diagnostic for Lithium-Ion Battery

Detection and quantitative diagnosis of micro-short-circuit faults in lithium-ion battery packs considering cell inconsistency

Quantitative Short Circuit Identification for Single Lithium-Ion Cell Applications Based on Charge and Discharge Capacity Estimation

Simultaneous diagnosis of cell aging and internal short circuit faults in lithium-ion batteries using average leakage interval

An Online Adaptive Internal Short Circuit Detection Method of Lithium-Ion Battery

Quantitative Diagnosis of the Soft Short Circuit for LiFePO4 Battery Packs Between Voltage Plateaus

Internal Short Circuit Detection for Battery Pack Using Equivalent Parameter and Consistency Method

Online internal short circuit detection for a large format lithium ion battery

Internal short circuit detection method for battery pack based on circuit topology

Accurate Measurement of the Contact Resistance During Internal Short Circuit in Lithium-Ion Batteries

Detection of internal short circuit in lithium-ion batteries based on electrothermal coupling model

Early stage internal short circuit fault diagnosis for lithium-ion batteries based on local-outlier detection

Internal short circuit detection for lithium-ion battery pack with parallel-series hybrid connections

Battery Internal Short Circuit Detection

Investigation on Early-stage Internal Short Circuit Identification for Power Battery Pack