Abstract:It is crucial to identify the battery's internal short circuit (ISC) for safety. The study aims to explore the effectiveness of ISC detection methods through battery aging. Two types of method are compared in this work: diffusion coefficient calculation based on electrochemical impedance spectroscopy and conventional internal resistance monitoring through algorithms such as recursive least square (RLS). In this work, the frequency-domain P2D model is built to simulate the behavior of the impedance response with different levels of ISC. Then, coin cells are assembled with conductive contaminants to examine the accuracy of the model simulation and the actual influences of the ISC on the impedance. Afterwards, with the proven impedance model and potential influences, the substituted ISC test on commercial 18,650 cells is applied to examine ISC detection based on EIS under different aging statuses. Finally, the conventional internal resistance identification method is used for comparison. The coin cell experimental results in the study indicate that the inception of the ISC mainly alters the low-frequency impedance with much reduced phases, which is also predicted by the model simulation. Similar results with the impacted low-frequency impedance can also be observed in the substituted ISC test for the commercial cells. The diffusion coefficients, the parameter mainly associated with the low-frequency impedance response, increased by 47–143 % as the battery SOH decreased from 100 % to 87 %. In comparison, the internal resistance identification method indicates that the ohmic component is relatively stable after the inception of the ISC. The polarization component of the internal resistance exhibits a significant change as high as 234 %. However, as the battery's SOH decreases, the effectiveness of the polarization resistance fades toward 23 %.

Simultaneous diagnosis of cell aging and internal short circuit faults in lithium-ion batteries using average leakage interval

An Early Micro Internal Short Circuit Fault Diagnosis Method Based on Accumulated Correlation Coefficient for Lithium-Ion Battery Pack

A battery internal short circuit fault diagnosis method based on incremental capacity curves

Disturbance-Immune and Aging-Robust Internal Short Circuit Diagnostic for Lithium-Ion Battery

Detection and quantitative diagnosis of micro-short-circuit faults in lithium-ion battery packs considering cell inconsistency

A Quantitative Method for Early-Stage Detection of the Internal-Short-circuit in Lithium-ion Battery Pack under Float-Charging Conditions

Quantitative Diagnosis of Internal Short Circuit for Lithium-Ion Batteries Using Relaxation Voltage

Early stage internal short circuit fault diagnosis for lithium-ion batteries based on local-outlier detection

Online detection of early stage internal short circuits in series-connected lithium-ion battery packs based on state-of-charge correlation

Internal Short Circuit Fault Diagnosis for Lithium-ion Battery Using a Novel Voltage Prediction Method

An Aging- and Load-Insensitive Method for Quantitatively Detecting the Battery Internal-Short-circuit Resistance

Fault Identification and Quantitative Diagnosis Method for Series-Connected Lithium-Ion Battery Packs Based on Capacity Estimation

Investigation and comparison of the electrochemical impedance spectroscopy and internal resistance indicators for early-stage internal short circuit detection through battery aging

Diagnosis Of Internal Short Circuit For Lithium Ion Battery Pack Under Varying Temperature

An Online Adaptive Internal Short Circuit Detection Method of Lithium-Ion Battery

Early Internal Short Circuit Diagnosis for Lithium-Ion Battery Packs Based on Dynamic Time Warping of Incremental Capacity

Quantitative Diagnosis of the Soft Short Circuit for LiFePO4 Battery Packs Between Voltage Plateaus

Detecting the internal short circuit in large-format lithium-ion battery using model-based fault-diagnosis algorithm

Capacity-Loss Diagnostic and Life-Time Prediction in Lithium-Ion Batteries: Part 1. Development of A Capacity-Loss Diagnostic Method Based on Open-Circuit Voltage Analysis

Incremental capacity analysis and differential voltage analysis based state of charge and capacity estimation for lithium-ion batteries

Research on short-circuit fault-diagnosis strategy of lithium-ion battery in an energy-storage system based on voltage cosine similarity