Abstract:Silicon -based ultra -thin flat heat pipes (UFHPs) that can be integrated with semiconductor devices provide an opportunity for electronic thermal management. To meet the requirements of various operation states, the impacts of gravity on the liquid plug characteristics and heat transfer performance of an UFHP are investigated by a visualization experiment conducted at different incline angles. Condensate flows back through microgrooves under the capillary pressure and gravity under a low heating power (capillary flow stage), and then excess condensate flows back along the edges of the UFHP under a higher heating power (gravitational flow stage). Over a certain heating power ( Q >= 14 W), liquid plug fluctuations caused by vapor entrainment are observed with periodic dry -out at the evaporator under large incline angles ( alpha >= 60 degrees ), corresponding to temperature fluctuations. Intense fluctuations of the liquid plug enhance sensible heat transfer, although the liquid plug occupies the condenser area and impedes the vapor flow. Meanwhile, evaporation at the evaporator benefits from corner -film evaporation until a large area of dry -out occurs. Due to the increased gravity and buoyancy, a larger incline angle is conducive to thermal performance enhancement, but this effect becomes restricted as the heating power rises. At a cooling -water temperature of 20 degrees C and an incline angle of 90 degrees , the lowest thermal resistances of the UFHP yield a value of 1.14 degrees C/W at 4 W in the steady stage and a value of 1.22 degrees C/W at 18 W in the fluctuation stage, respectively. The heat transfer limit of UFHP with overfilling reaches 24 W, compared with the theoretical heat transfer capacity of 8.9 W at an incline angle of 90 degrees . Additionally, a higher cooling -water temperature is beneficial for the thermal performance in the capillary flow stage, but not in the gravitational flow stage and fluctuation stage. This study provides guidance for the operational design of silicon -based UFHP for electronic thermal management.

Heat Transfer Performance of the L-shaped Flat Gravity Heat Pipe Used for Zero-Carbon Heating Houses

Solar Application Potential and Thermal Property Optimization of a Novel Zero-Carbon Heating Building

Towards Zero-Carbon Solar Heating in Severe Cold and Cold Regions of China by Building Integrated Heat Pipes

Towards Zero Energy Buildings: A Novel Passive Solar House Integrated with Flat Gravity-Assisted Heat Pipes

Experimental Study on Flat Loop Heat Pipes Used in HCPV Systems

Performance Evaluation and Analysis of a Vertical Heat Pipe Latent Thermal Energy Storage System with Fins-Copper Foam Combination

Liquid Plug Characteristics and Heat Transfer Performance of a Silicon-Based Ultra-Thin Flat Heat Pipe at Different Incline Angles

Thermal performance and optimization of an integrated collector–storage solar air heater based on lap joint-type flat micro-heat pipe arrays

Design, Fabrication and Experimental Study of A Novel Loop-Heat-Pipe Based Solar Thermal Facade Water Heating System

Experimental investigation on a flat loop heat pipe coupled with thermoelectric cooler

Dynamic heat transfer characteristics of gravity heat pipe with heat storage

Experimental Study on Loop Heat Pipe with Flat Evaporator at Different Tilt Angles

Experimental study on a rectangular evaporator loop heat pipe with a phase-change material heat sink

Experimental study on heat transfer and storage of a heating system coupled with solar flat heat pipe and phase change material unit

Experimental investigation for the loop heat pipe with a bifacial flat evaporator

Experimental Investigation on the Active Thermal Management of Grooved Flat Heat Pipe under the Electrohydrodynamic Effect

Assessment of the Cost Reduction Potential of a Novel Loop-Heat-pipe Solar Photovoltaic/thermal System by Employing the Distributed Parameter Model

Design and Experimental Analysis of Grooved Flat Aluminum Heat Pipe

Experimental comparison and numerical study of flow and heat transfer characteristics of the pipe rows in heat pipe heat exchanger

Theoretical Investigation of the Thermal Performance of a Novel Solar Loop-Heat-pipe Façade-Based Heat Pump Water Heating System

Experimental, Study and Design Sensitivity Analysis of a Heat Pipe Photovoltaic/thermal System