Abstract:Abstract The coastal pipelines are the key link between the offshore and the onshore pipelines, which are located in the soil dry-wet alternating environment. Even though higher corrosion risk of metals in coastal soil dry-wet alternating environment, few papers focused on this condition, while much research about ocean and atmospheric dry-wet alternating environment was paid attention to. In this paper, a self-designed soil dry-wet alternating experimental device was used to investigate the corrosion characteristics of Q235 steel in seawater, soil and dry-wet alternating environment based on mass loss experiments, corrosion morphology analysis and electrochemical experiments. The results showed that the general corrosion rate of Q235 steel in soil and seawater environments basically remained unchanged, and in dry-wet alternating environment increased with time, while the pitting rates were 0.280 mm/a (soil), 0.420 mm/a (seawater) and 0.567 mm/a (dry-wet alternation), respectively, which was caused by the oxygen concentration cell and salt concentration cell. Meanwhile, the growth rate of pitting size in dry-wet alternating environment was much higher than that in the other two environments with different corrosion characteristics of pitting corrosion (seawater and dry-wet alternation) and a changed from general corrosion to pitting corrosion (soil). In three environments, the corrosion current density ( I corr ) increased, in which on the 30th day of experiment, I corr = 79.72 μ A cm −2 in dry-wet alternating environment, which was much higher than I corr = 47.89 μ A cm −2 in seawater environment. In dry-wet alternating environment, the mass diffusion impedance at 10 –2 Hz and the maximum phase angle changed significantly, while the log f -log∣ Z ∣ curve in low-middle frequency decreased significantly, and charge transfer resistance at 10 5 Hz reduced from 10.4 Ω to 4.3 Ω, illustrating an increasing corrosion rate.

Towards Understanding of Corrosion Behaviors of Q235A Pipeline Steel Subjected to Simulated Direct Stray Current Interference in Different Electrolytes

Corrosion Behavior of X80 Steel in a Simulated Soil Solution Under Square-Wave Current Interference

Numerical Simulation of Stray Current Corrosion of Buried Steel Pipeline under Cathodic Protection

Effects of Alternating Stray Current on the Corrosion Behaviours of Buried Q235 Steel Pipelines

Unraveling mechanisms and failures of stray current corrosion in urban Subway adjacent pipeline networks through statistical insights and 3D simulation

Research on the Corrosion Behavior of Q235 Pipeline Steel in an Atmospheric Environment through Experiment

Stray Current Corrosion of Q235 Steel in Hainan Soil

Assessment of interference scope induced by stray current in the metro depot for the corrosion risk of buried metal pipeline

Multi-physics coupled simulation and experimental investigation of alternating stray current corrosion of buried gas pipeline adjacent to rail transit system

Research on corrosion rate assessment of buried pipelines under dynamic metro stray current

Electrochemical Study on the Macro-Cell Corrosion of Pipeline Steel Partially Covered by Different Kinds of Mineral Deposits

Study on corrosion characteristics of Q235 steel in seawater, soil and dry-wet alternating environments focusing on Shengli oilfield

Remaining lifetime assessment of gas pipelines subjected to stray current interference using an integrated electric-electrochemical method

Electrochemical and Stress Corrosion Mechanism of Submarine Pipeline in Simulated Seawater in Presence of Different Alternating Current Densities

Stray current corrosion behavior of Q2 3 5 carbon steel grounding material

Experimental research on the corrosion of X series pipeline steels under alternating current interference

Corrosion Behaviors of X80 Pipeline Steel in Different Simulated Alkaline Soil Solution

Experimental study on pipeline corrosion behavior coupled with microorganisms and dynamic alternating current interference

Role of Sulfide Ion on Corrosion Performance of Pipeline Steel in Simulated Inner-Seeper Environment

Effect of Magnetic Field on Corrosion Behavior of X52 Pipeline Steel in Simulated Soil Solution: PART II. Influence of Direct Current Stray

Electrochemical Corrosion Behavior of X80 Pipeline Steel in Simulated Medium of Saline-alkali Soil