Abstract:Al2O3, as one of the gate dielectric materials for thin film transistors (TFTs), has been extensively investigated because of its large bandgap, high breakdown field, and good thermal stability. However, the further development of Al2O3 thin films is limited by the presence of defects such as oxygen vacancies, self-interstitial atoms, or impurity elements. To overcome this obstacle, we have developed a novel method for fabricating Al2O3 thin films by using the atomic layer deposition (ALD) technique. This method replaces the conventional Trimethylaluminium (TMA)/H2O cycles with TMA/TMA/H2O/H2O cycles (referred to as 'double cycles'), to deposit the Al2O3 . The 5-nm ultrathin Al2O3 film showed a high areal capacitance of 660 nF/cm(2) at 20 Hz, and a relatively low current density of 10(-8) A/cm(2) at 1 MV/cm. InGaZnO (IGZO) TFTs with ultrathin Al2O3 gate dielectric grown by double cycles exhibited outstanding performances, such as a near theoretical limit subthreshold swing (SS) of 70 mV/decade, a higher on/off current ratio (I-on/I-off) of 106, an increased field-effect mobility (mu) of 6.5 cm(2)/Vs, a lower threshold voltage (V-th) of 0.2 V, and a low operating voltage of 3 V. These results are superior to the IGZO TFTs with Al2O3 dielectrics deposited using the single TMA/H2O cycle. Therefore, the implementation of 'double cycles' in the fabrication of dielectrics through ALD demonstrates considerable potential for future application in low-power electronic devices.

Air Stable High Mobility ALD ZnO TFT with HfO<inf>2</inf> Passivation Layer Suitable for CMOS-BEOL Integration

Air Stable High Mobility ALD ZnO TFT with HfO<sub>2</sub> Passivation Layer Suitable for CMOS-BEOL Integration

P‐1.11: High‐mobility ZnO thin‐film transistors with HfO<sub>2</sub>/Al<sub>2</sub>O<sub>3</sub> bilayer dielectric

Enhanced Stability Performance of Transparent Ozone ALD ZnO Thin-Film Transistors with SiAlOX Dielectric

High Mobility Solution-Processed Hafnium Indium Zinc Oxide TFT with an Al-Doped ${\rm ZrO}_{2}$ Gate Dielectric

Field-Effect Mobility Enhancement in Low Temperature ALD ZnO Thin-film Transistors Via Contact Defects Engineering Suitable for BEOL Integration

High Mobility Amorphous Indium-Gallium-Zinc-Oxide Thin-Film Transistor by Aluminum Oxide Passivation Layer

High Mobility Thin-Film Transistor with Solution-Processed Hafnium-Oxide Dielectric and Zinc-Indium-Tin-Oxide Semiconductor

Feasibility of Atomic Layer Deposited AlZrOx Film to Achieve High Performance and Good Stability of ZnSnO-TFT

Enhanced Performance of Atomic Layer Deposited Thin-Film Transistors with High-Quality ZnO/Al 2 O 3 Interface

59.9 mV·dec Subthreshold Swing Achieved in Zinc Tin Oxide TFTs With In Situ Atomic Layer Deposited AlO Gate Insulator

Back-End-of-Line Compatible InSnO/ZnO Heterojunction Thin-Film Transistors With High Mobility and Excellent Stability

High mobility of IGO/IGZO double-channel thin-film transistors by atomic layer deposition

Huge mobility enhancement of InSnZnO thin-film transistors via Al-induced microstructure regularization

CMOS backend-of-line compatible memory array and logic circuitries enabled by high performance atomic layer deposited ZnO thin-film transistor

High-Performance of InGaZnO TFTs With an Ultrathin 5-nm Al<sub>2</sub>O<sub>3</sub> Gate Dielectric Enabled by a Novel Atomic Layer Deposition Method

15.2: Invited Paper: Atomic Layer Deposited Oxide Semiconductor Enabling High Mobility and Low Driving Voltage in TFTs

Mobility and Stability Enhancement of Amorphous In-Ga-Zn-O TFTs with Atomic Layer Deposited Al2O3/SiO2Stacked Insulators

High Performance Aluminum-Doped Zno Thin Film Transistors with High-K Gate Dielectrics Fabricated at Low Temperature

47-4:Invited Paper: Flexible AMOLED Based on Oxide TFT with High Mobility

Enhancing the Stability and Mobility of TFTs via Indium-Tungsten Oxide and Zinc Oxide Engineered Heterojunction Channels Annealed in Oxygen Ambient