Abstract:Microscale boiling heat transfer experiments were performed using acetone as the working fluid in ten parallel silicon microchannels with hydraulic diameters of 155.4 mum. An infrared radiator image system is used for the chip temperature measurements, while an optical system combining a microscope and a high-speed camera is used for transient flow pattern identification. By covering the present data range it is found that all microchannels repeat the transient flow patterns in a timescale of milliseconds while the fluid pressures/temperatures are stable. A full cycle can be subdivided into three substages: liquid refilling stage, bubble nucleation, growth and coalescence stage, and transient annular flow stage. Correspondingly four flow patterns are identified. Paired or triplet bubbles are observed to be nucleated and grow up simultaneously in, or very close to, the channel corners at the same cross section. The nucleated bubbles experience several milliseconds of growth until coalescence takes place. Then a single liquid plug is separated into two parts, which are pushed out of the flow field view in less than 1 ms. In the transient annular flow stage, the liquid films that are drawn into the comers of the channel become less and less versus time. Once a partially or fully dried-out state is reached, all the microchannels are refilled with fresh liquid and a new cycle begins. The probabilities of each flow pattern occurring and the liquid refilling follow the statistical principle well. The measured chip temperatures are not uniform across the whole heating area, attributed to the uneven liquid refilling probabilities for different channels and the uneven possibilities that are immersed in the liquid for different heating regions. The chip temperatures display spatial variation behavior in the majority of the heating area, due to the liquid and vapor alternatively passing through the microchannels. To the authors' knowledge, some of the above experimental findings have not been previously reported.

Millisecond Time-Scale Measurements of Heat Transfer to an Open Bath of He II

Millisecond Time-Scale Measurements of Heat Transfer to Confined He II

Experiments on the Transient Heat Transfer of Minichannel Heat Sink under High Heat Flux Density in an Enclosed Loop

Measurement of Boiling Heat Transfer Coefficient in Liquid Nitrogen Bath by Inverse Heat Conduction Method

Measurement and Comparison of Transient Thermal Boundary Layer of a Local-Heated Mini-Channel under Sub- and Super-critical Conditions

Experimental setup for comprehensive study of non-stationary heat transfer in complex liquid media

Measuring time-resolved heat transfer fluctuations on a heated-thin foil in a turbulent channel airflow

Molecular Dynamics Simulations of Non-Fourier Heat Conduction

INVESTIGATION OF A QUASI-STEADY LIQUID CRYSTAL TECHNIQUE FOR FILM COOLING HEAT TRANSFER MEASUREMENTS

Investigation of turbulent flow in square duct with heated foil thermometry

Microscale Boiling Heat Transfer in A Micro-Timescale at High Heat Fluxes

Microbubble Formation Dynamics under High Heat Flux on Heaters with Different Aspect Ratios

Flow Boiling Heat Transfer in A Minichannel with Enhanced Heating Surface

Influence of the Surface Enhancement on the Flow Boiling Heat Transfer in a Minichannel

Flow Visualization and Local Measurement of Forced Convection Heat Transfer in a Microtube

Transient Oscillatory Saturated Flow Boiling Heat Transfer and Associated Bubble Characteristics of FC-72 over a Small Heated Plate Due to Heat Flux Oscillation

An Ultra-Fast TSP on a CNT Heating Layer for Unsteady Temperature and Heat Flux Measurements in Subsonic Flows

Investigations of Flow Boiling in Mini-Channels: Heat Transfer Calculations with Temperature Uncertainty Analyses

Heat Transfer Enhancement and Interaction of Rivulets on the Surface of a Heated Liquid Film

AN EXPERIMENTAL INVESTIGATION OF OSCILLATORY HEAT TRANSFER IN HELICAL COILED TUBE WITH STEAM WATER TWOPHASE DENSITY WAVE OSCILLATION FLOW

Influence of the Switch-Over Period of an Alternately Active Bi-Heater on Heat Transfer Enhancement Inside a Cavity