Abstract:The introduction of heterostructures is a new approach in gas sensing due to their easy and quick transport of charges. Herein, facile hydrothermal and solid-state techniques are employed to synthesize an α-Fe2O3/Nb2O5 heterostructure. The morphology, microstructure, crystallinity and surface composition of the synthesized heterostructures are investigated by scanning electron microscope, transmission electron microscope, x-ray diffraction, x-ray photoelectron spectroscopy and Brunauer–Emmett–Teller analyses. The successful fabrication of the heterostructures was achieved via the mutual incorporation of α-Fe2O3 nanorods with Nb2O5 interconnected nanoparticles (INPs). A sensor based on the α-Fe2O3(0.09)/Nb2O5 heterostructure with a high surface area exhibited enhanced gas-sensing features, maintaining high selectivity and sensitivity, and a considerable recovery percentage towards ethanol gas. The sensing response of the α-Fe2O3(0.09)/Nb2O5 heterostructure at lower operating temperature (160 °C) is around nine times higher than a pure Nb2O5 (INP) sensor at 180 °C with the flow of 100 ppm ethanol gas. The sensors also show excellent selectivity, good long-term stability and a rapid response/recovery time (8s/2s, respectively) to ethanol. The superior electronic conductivity and upgraded sensitivity performance of gas sensors based on the α-Fe2O3(0.09)/Nb2O5 heterostructure are attributed due to its unique structural features, high specific surface area and the synergic effect of the n–n heterojunction. The promising results demonstrate the potential application of the α-Fe2O3(0.09)/Nb2O5 heterostructure as a good sensing material for the fabrication of ethanol sensors.

Ethanol Gas Concentration Detection System Based on Infrared Spectrum

Stand-off detection of ethanol gas in turbulent state using a 1.7 m/1.5 m near-infrared spectroscopy system

Room-Temperature Ethanol Sensors Based on Amorphous Ta2O5/Pd Hybrid Microspheres

A reusable optical fiber sensor for ethanol gas detection with a large concentration range

Design of Highly Sensitive and Selective Ethanol Sensor Based on Α-Fe2o3/nb2o5 Heterostructure.

Infrared Evanescent Wave Sensing Based on a Ge10As30Se40Te20 Fiber for Alcohol Detection

High sensitivity ethanol vapor sensor based on a nematic liquid crystal film embedded optical fiber Sagnac interferometer

High-sensitivity determination of ethanol concentration based on weak measurement system with Faraday effect

Dual-wavelength Rapid Excitation Raman Difference Spectroscopy System for Direct Detection of Ethanol in Illegal Beverages

Development of a Sensitive Gas Sensor by Trapping the Analytes on Nanomaterials and in Situ Cataluminescence Detection

The Near Infrared Spectral Bands Optimal Selection in the Application of Liquor Fermented Grains Composition Analysis]

Gas Sensor Based on Surface Enhanced Raman Scattering

Ethanol Gas Sensor Based on a Hybrid Polymethyl Methacrylate–Silica Microfiber Coupler

CuO/TiO2/MXene-Based Sensor and SMS-TENG Array Integrated Inspection Robots for Self-Powered Ethanol Detection and Alarm at Room Temperature

Gas/liquid Detection System Based on Intra-Cavity Absorption Spectroscopy and Tilted Fiber Bragg Grating

Smart Hydrogel Gratings for Sensitive, Facile, and Rapid Detection of Ethanol Concentration

A hydrogel optical fiber sensor for rapid on-site ethanol determination

Characterizing the concentration of ethanol-water solutions by oblique-incidence reflectivity difference combined with deep learning algorithms

Study on System for Extracted Type Infrared Gas Analysis

An Ethanol Vapor Sensor Based on a Microfiber with a Quantum-Dot Gel Coating.

Highly sensitive and low detection limit of ethanol gas sensor based on CeO2 nanodot-decorated ZnSnO3 hollow microspheres